Question about Hyundai Motor 2002 Sonata

Open Question

I am working on a 2002 Hyundai Sonata with 2.4L engine. Problem is that the fuel pressure drops to zero as soon as the pump shuts off, thereby causing extended crank time after car has been sitting. There has been 2 fuel pumps, a pressure regulator and the fuel filter replaced.The fuel filter is aftermarket. Did the OE filter have the check valve intregal?

Posted by on

Ad

6 Suggested Answers

6ya6ya

6ya staff

  • 2 Answers

SOURCE:

Hi there,
Save hours of searching online or wasting money on unnecessary repairs by talking to a 6YA Expert who can help you resolve this issue over the phone in a minute or two.

Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.

Here's a link to this great service

Good luck!

Posted on Jan 02, 2017

Ad

Jaime Hernandez

  • 2337 Answers

SOURCE: car doesn't seem to get enough gas to engine

Have you done a tune lately on the car?
I would also suspect a fuel pump problem is you've done a tune up recently.

Posted on Jul 11, 2008

Ad
localwonder

Michael Masters

  • 6784 Answers

SOURCE: location of fuel pump relay (1990 hyundai sonata)

The fuse box is located low on the left side of the dashboard behind a cover, or at the left side kick panel, behind a cover.

Relay Box -is located under the left side of the dash as well.


3a53806.jpg

Posted on May 07, 2009

Scott

  • 68 Answers

SOURCE: how do you replace a window regulator on a 2001

Go to the free Kia tech website: http://www.kiatechinfo.com/index.asp You will find detailed instructions under the 2001 "MS" series Kia Optima. It is exactly the same as your Sonata. The site is free and anybody can access it. Just register, and allow some time to learn to navigate around. it can be tricky at first. Good luck, and remember to have your window securly taped fully closed. this will make it easier and quicker. best of luck!

Posted on Jan 30, 2010

jason jackson

  • 395 Answers

SOURCE: replaced fuel pump in 2000 hyundai elantra and

well if she ran it to long with no oil it might be locked up and might be able to turn it over if its not to bad. but you should still get power going to your fuel pump i would check all connection going to fuel pump and no broken wires. try even un plugging battery to see if there's a bypass

Posted on May 05, 2010

Rajkumar S

  • 104 Answers

SOURCE: 2001 hyundai sonata wiring diagram

You don't required to search for the wiring diaghram. These are standard in the wiring harness from the manufacturer. You need to look for the socket which may folded inside the console in front of you. Fix the audio in position and connect the cable socket for your new audio.

Posted on Jun 05, 2010

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Where is the fuel pump relay located at in a 2002 Hyundai sonata v6


If you need to know the fuel pump relay of your Hyundai Sonata, then here I have mentioned the video which shows you 07 Hyundai Sonata 3.3 fuel pump relay location, have a look

Dec 10, 2017 | Hyundai Cars & Trucks

1 Answer

WHERE IS THE FUEL CUTOFF SWITCH ON THE 2007 HYUNDAI SONATA


No cutoff switch on Hyundai cars. Only Ford products.
The fuel pump and injectors get power from the engine control relay.

Feb 19, 2013 | 2007 Hyundai Sonata Limited Sedan

1 Answer

Where is the Fuel safety shut off valve on a 2008 Sonata?


The only brand I know of that has a safety valve for the fuel pump is Ford.
If you have no fuel pressure I would check for voltage at the pump relay.

Aug 07, 2012 | 2008 Hyundai Sonata

1 Answer

Im gettin 11.9 mpg in 92 sonata 6 cylinder(3.0) I was told it could b my brain box. Would that be the engine control unit or the engine control module?


You have an engine control unit, but that is rarely the problem. Is your engine light on? If yes, let me know and I'll send procedures for extracting the trouble codes that may identify the problem.
If no engine light, the first thing I would check is the fuel pressure regulator. Pull the vacuum hose off the regulator and plug it with a golf tee. Start the engine and see if gas comes out the vacuum port on the regulator. Is indicates a busted diaphram. Even if the diaphram is good, I would then borrow a fuel pressure gage and run the tests below to make sure the regulator is working to keep the pressure at 39psi. Let me know if this isn't it or you have more questions.

  1. Relieve fuel system pressure.
  2. Turn ignition switch OFF and disconnect the negative battery cable.
When disconnecting any fuel system hoses, always place a shop towel to prevent residual fuel from spaying.
  1. Disconnect the high pressure hose at the delivery side. Using a fuel pressure gauge and adapter (09353-24000 or equivalent), install the adapter to the delivery pipe.
  2. Connect the negative battery cable.
  3. Activate the fuel pump, by applying battery voltage to the fuel pump drive terminal. Check that there is no leakage from pressure gauge or connections.

jturcotte_284.gif


Fig. Fig. 12: Fuel pump drive terminal location-Excel

  1. Disconnect the vacuum hose from the pressure regulator and plug.


jturcotte_285.gif


Fig. Fig. 13: Fuel pump drive terminal location-Sonata

  1. Operate the engine at idle and check the fuel pressure. Fuel pressure should be 47-50 psi (330-350 kPa).
  2. Reconnect the vacuum hose to the pressure regulator. With the engine idling, fuel pressure should be 39 psi (270 kPa).
  3. If the specified values are not met, make the necessary repairs, as indicated in the diagnosis chart.
  4. Shut the engine OFF. Check that the fuel pressure is maintained at the value indicated in Step 8, for approximately 5 minutes.
  5. Relieve the fuel pressure.
  6. Remove the fuel pressure gauge and reconnect the high pressure hose, using a new O-ring.
  7. Start the engine and check for leaks.

Nov 25, 2010 | 1992 Hyundai Sonata

1 Answer

When trying to re-fuel my 2002 Hyundai Sonata GLS, the pump keeps shutting off as if the tank was full. I can get maybe a gallon at a time before it shuts off. Any ideas?


the vent valve in the tank is not working correctly,you need to ask a dealer if there are any technical service bulletins on this problem

Dec 25, 2009 | Hyundai Motor 2002 Sonata

1 Answer

My 2002 hyundai sonata acted like it wasnt getting enough fuel .we changed the fuel filter and the fuel pump now im not getting power to the fuel pump and the fuses are all good.HELP


check the impact saftey switch to see if it was tripped it should be listed in your owners manuel. It is a saftey feature in case of a collision it shuts down the fuel pump

Oct 16, 2009 | Hyundai Motor 2002 Sonata

1 Answer

Fuel pressure drops immediately to zero when engine is shut off.


I am not really familiar with the setup there but I'd be looking for a second relay to kick the pump on when cranking.

Jun 05, 2009 | 1991 Dodge Dynasty

Not finding what you are looking for?
Hyundai Motor 2002 Sonata Logo

Related Topics:

82 people viewed this question

Ask a Question

Usually answered in minutes!

Top Hyundai Experts

Marvin
Marvin

Level 3 Expert

85206 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22484 Answers

Jonah Oneal

Level 3 Expert

14092 Answers

Are you a Hyundai Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...