SOURCE: battery location for a 2004 suzuki intruder 800
Hi ...... Find where the battery is, under the seat or behind a side panel. Disconnect the black (negative lead usually with a 10mm spanner then disconect the red (positive) lead. The battery will be held in place with a 'rubber' strap or a bracket and depending on type of battery there may be a vent hose from the battery to the lower half of the bike, this just pulls off and remains in place until you replace the battery. Installation is reverse except you connect red (positive) first.
Let us know how you get on.
SOURCE: battery removel for a 2004 suzuki 800 intruder
the battery is under the bike, bottom of box hinges down, just in front of rear wheel.
pain in the ***
some recomend parking bike wheels and kickstand on board for better access.
SOURCE: battery removel for a 2004 suzuki 800 intruder
I know for the models till 2002 where the battery is located in front of the rear wheel.
Place the bike on her side stand
remove the negative battery lead at the left side, just below the transmission tube ( cone ) 10mm socket wrench
On the right side remove the security cap on the positive lead ( cross screwdriver ), then remove the positive lead.
The battery is hold in place with a 'floor plate'. remove both bolts of the floorplate ( on each side ) while holding the palte into place.
gently lower the plate and the battery.
I hope the 2004 model has the same assembly!
SOURCE: How do you remove and install a new fork lock?
YOU WILL NEED TO REMOVE THE TRIPLE TREE FROM THE FRAME TO ACCESS THE LOCK. ONCE YOU GET THE STEERING SHAFT REMOVED FROM THE FRAME YOU WILL SEE HOW TO REMOVE IT.
SOURCE: Suzuki intruder 1500 charging system
You need to buy a volt meter and set it on 10, or 20 v-. Start the bike and see what it says. A good charging system will show 13-14+ volts. If the meter says 11-12 volts or does not change, you have a bad stator, or rect/reg. Take to a shop to have it further tested. Chaz Moto DC
228 views
Usually answered in minutes!
×