2003 Volvo V40 Logo
A
Anonymous Posted on Nov 22, 2011
Answered

How do you replace the alternator in a 2003 V40? no manual available on our island...

Answer This Question

1 Answer

Jeffrey Turcotte

Jeffrey Turcotte

Level 3:

An expert who has achieved level 3 by getting 1000 points
Superstar:

An expert that got 20 achievements.
All-Star:

An expert that got 10 achievements.
MVP:

An expert that got 5 achievements.

  • Volvo Master 8,991 Answers
  • Posted on Nov 22, 2011
Jeffrey Turcotte
Volvo Master
Level 3:

An expert who has achieved level 3 by getting 1000 points
Superstar:

An expert that got 20 achievements.
All-Star:

An expert that got 10 achievements.
MVP:

An expert that got 5 achievements.

Joined: Aug 22, 2010
Answers
8991
Questions
7
Helped
4373307
Points
33683

NOTE Make a note of the anti-theft radio code

  1. Remove or disconnect the following:

    Engine splash guards, if equipped Negative battery cable Drive belt Power steering pump Mounting bracket Connector and wiring Upper mounting screw Upper screws for the air conditioning (A/C) compressor. Move the screws approximately 30 mm forward. Lower screws for the air conditioning (A/C) compressor Alternator

how do you replace the alternator in a 2003 V40? n - 11_22_2011_3_09_12_am.gif

    Fig. Typical alternator mounting


    To install:
    Install or connect the following:


    Alternator Upper bolt. Do not tighten Mounting bracket Two bolts for the air conditioning compressor Tighten bolts to 18 ft. lbs. (25 Nm) Connector and wiring Power steering pump Drive belt Negative battery cable Engine splash guards, if equipped







Add Your Answer

×

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

0helpful
1answer

2003 Volvo v40 Runs awesome Won't pass smog because check engine light won't light. wouldn't it throw a code if it had a bad connection or broken wire? No codes it just doesn't work. HELP
There is a light bulb inside the dashboard that needs to be replaced. You unscrew the dashboard and then unclip the dash cluster out from the dashboard and replace the bulb behind the check engine light slot. Should take less than a half hour. Most auto parts stores stock the bulbs.
Read full answer
Feb 10, 2017 • 2003 Volvo V40
0helpful
1answer

Will a 1.6 1999 s40 engine fit in a 2003 1.6 v40 car thanks
gee thats a good question .
will you use the 1999 engine bay loom and ECU fuel pump
V40 engine plug connections may differ ?
v40 top
S40 bottom .


26198948-n0ieczzenqorbcrwwih4mmb1-4-2.jpg26198948-n0ieczzenqorbcrwwih4mmb1-4-2_1.jpg
Read full answer
May 19, 2016 • Cars & Trucks
0helpful
1answer

MY 1997 DODGE DAKOTA HAS A 2003 BLOCK NOT A 2004
What was the original question?
Read full answer
Feb 02, 2015 • Dodge Cars & Trucks
0helpful
2answers

Why is my volvo v40 trying to overcharge its battery, and what can I do about it?
Did you check the fluid in the battery. Level ok?
But the more worrying thing is the voltage regulator is not working properly anymore. Check the manual, to see at what voltage it should stop and measure if it does.
Read full answer
Jun 11, 2014 • 2000 Volvo V40
1helpful
1answer

Noise on engine
I have the same problem in my car volvo v40 1.6. A mechanic told me that this noise did VVT Pulley and should be changed.
Read full answer
Oct 11, 2012 • 2000 Volvo V40
0helpful
1answer

I have a 2003 v40 that has had the blower (a/c - heater) stuck on the high speed and as I went to turn the control knob back and forth, the fan just totally quit. What to do?
It sounds like the switch is bad.
Read full answer
Dec 13, 2010 • 2003 Volvo V40
0helpful
1answer

Where can i get dashlight bulbs for a volvo v40 2004. Not at a dealers. I live in the republic of ireland Thanks Neil
Any auto parts store they can look up the part number or buy replacements online through Auto Zone.
Read full answer
Nov 30, 2009 • 2003 Volvo V40
3helpful
1answer

How to replace an alternator. Ford econoline 150
I suggest checking out the autozone.com website and register the vehicle. It doesn't cost anything and will give you access to an online repair manual. The steps for replacing the alternator should be available there. Hope this helped and best wishes.
Read full answer
Sep 04, 2009 • 2003 Ford E150
0helpful
1answer

Can I replace a bulb in the offside headlight of a V40?
u need a special tools and it's expensive i suggest to go to any local garage
Read full answer
Aug 13, 2009 • 2003 Volvo V40
0helpful
1answer

VOLVO BREAK PADSD
better off bringing to a mechanic unlike the front brakes,where you can push the piston back the back are different where the piston has to be screwed back with a special tool.
Read full answer
Jun 30, 2008 • 2003 Volvo V40
Not finding what you are looking for?

View Most Popular

2003 V40

  • Cars & Trucks

Related Question

2003 Volvo v40 Runs awesome Won't pass smog because check engine light won't light. wouldn't it throw a code if it had a bad connection or broken wire? No codes it just doesn't work. HELP

  • 2003 Volvo V40

Related Topics

381 views

Ask a Question

Usually answered in minutes!

Popular Questions

Timing marks on a 2000 volvo v40 1.9t

2000 Volvo V40

Hello , where is the handbrake adjuster on volvo v40 - 53reg

2003 Volvo V40

Need timing belt diagram

2000 Volvo V40

Volvo v40 radio

2000 Volvo V40

How to adjust headlights on 2001 volvo V40

2000 Volvo V40

Check Out the Latest Top Trucks Report!
Check Out the Latest Top Trucks Report!

View all Fixya Reports

Top Volvo Experts

ZJ Limited
ZJ Limited

Level 3 Expert

17989 Answers

Thomas Perkins
Thomas Perkins

Level 3 Expert

15088 Answers

john h

Level 3 Expert

29494 Answers

Are you a Volvo Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...