My 2002 kawasaki zx6r is over heating the temperture goes past 240 then it say high now I see the fan is not coming on anymore.

This is all I could find in my service documents. Hope this helps.

sounds like lack of fuel or blockage check pressure regulator,fuel pump.

I would look at the coolant temp with a scan tool the fans should come on when the coolant gets around 240 degrees. If the scan tool shows about 240 and the gauge shows higher than the gauge is the problem.

I’m happy to assist further over the phone at https://www.6ya.com/expert/jeremy_d728a59f986299fa

I don't know if you can adjust it but mine was running hot so I tried I believe it's called Blue Ice coolant brought my temp down by 15-20 deg just make sure you follow the directions

P1296 for 2002 Vw Passat pertains to a cooling system malfunction. The therostate or the ECT ( temperture senser for coolant for the computer has malfuntioned ) Under heating and overheating and the wire coming off or being pinched to grong of the coolant temperture senser. The senser is located near the therostate housing and it can be damages by overheating ( fan not coming on as needed or freezing ( antifreeze not up to correct level.

You could try link if you have the 600cc at £6.95 + pnp,
http://www.bitzforbikes.co.uk/Kawasaki/ZX-6R_%28ZX_600%29/%28ZX_600%29_J1_-_J2_00_-_01/Air_and_Oil_Filters
Part number is HL380360
or if you have the 636cc at also 6.95
http://www.bitzforbikes.co.uk/Kawasaki/ZX-6R_%28ZX_636%29/%28ZX_636%29_A1P_02/Air_and_Oil_Filters
Part number is HL380380

I can fix this for you. Where are you residing please? Thanks David. "The Famous Forry'

the horn is only held on by 1 bolt,undo this and remove the 2 wires then just reverse these steps to refit

With the 05 I would check the thermostat. With the 03 that is normal, my 02 cuts on and off around the same range. I put a switch in so I could turn my fan on when ever I wanted. I run mine once I get to 175...