SOURCE: 2000 GMC Sierra 5.3 Litre, won't blow hot air
I experienced the same head ache. First attempt was to replace the thrmostat and after taking it apart I realized that there was nothing wrong with it. I then removed the plastic cover/panel located under the dash board on the passenger's side. (only a few 4-5 smalls screws) Removal will enable you to see the on/off switch/gate moving/rotating as you turn the knob to hot or cold positions, on the control panel. If that switch/gate seems to work ok, then the trouble is within the heater core. Many mechanincs suggested that I replace the heater core. A very expensive proposition.
I checked the heater core supply/intake hose and found it hot to the touch, while the return hose was nearly cold. It was definitely a heater core blockage. I removed both ends (supply and return) hose connections/clamps. They are located near the fire wall in the engine compartment. A special tool is very helpful to remove those clamps easily and to replace them as well. It can be done the old fashion way but this tool was a life saver and reduced work time to just minutes. (Tool is $70.00 bucks at auto parts store,so I borrowed mine from a mechanic/friend)
I then hooked up a garden hose to the return end of the heater core and reversed the flow of coolant/water through the heater core. My truck is a Sierra 2000 and I refuse to see how a heater core could get clogged up with clear coolant alone. To my surprise a flat piece of rubber about the size of a quarter blew out of it and the flow of water became unobstructed. I reconected the ends of the hoses to the heater core, replaced the lost antifreeze & everything returned back to normal. No money spent for something most mechanics suggested I replace control valves/switches ($280.00) replace heater core ($500.00) etc etc. I am glad I was curageous enough to tackle this myself and save a few pennies. Good luck, and I hope this will work for you.
SOURCE: AC is cold, then hot..
you need the tempature blend door motor. My 01 silverado had this issue about 1 1/2 years before i was tired of messing with it they are not hard to replace. The cover (if it is still on) for passenger side floor ducts needs to be removed and the motor is near the right side of "hump" (trans tunnel) mounted horisontial with the armature pointing upwards.
SOURCE: ac is blowing warm air in my 2005 sierra 2500hd duramax. Any idea
Your system has R-134 Freon in it. the 134 is made up of smaller molecules than the old R-12. The R -134 permeates through the rubber parts of the system. If the system gets too low on Freon, the compressor will stop coming on.(low pressure cut out switch). Have the system serviced with an A.C. machine that can vacuum, measure the amount of Freon in the system, and add the right amount. The machine can also inject die. Later the die will show up under a black light.This will show any leaks you may have.
SOURCE: 2002 GMC Savana 2500 Front AC warm, rear AC cool/cold
Typical symptoms of being a little low on refrigerant.
SOURCE: my ac blows cold air for the first 5-7 min then
have the low side pressure cycling switch tested.
40 views
Usually answered in minutes!
×