My pace edward tonneau cover will not retracted all the way

Funny, I thought this question had two answers? One was by the Indian AI Answer Bot Raja Akhter since deleted and another poster who said the brake was in the rear bed front left hand side. Not a lot of use as you said it works with the brake released.

You say you are getting no response. I always find it is better to phone. Speak to a real person in Support / R&D. It sounds like you have a relay problem. The clicking it the relay trying to switch power to the motor.

The phone number is at the bottom of the page. How old it is? Under warranty? The warranty is 7 years. What did the local dealer say?

https://www.leer.com/s/paceedwards

ULTRAGROOVE ELECTRIC BEDLOCKER® /BEDLOCKER MATTE For a period of seven (7) years from the date of purchase the Pace Edwards electric retractable cover has the following limited warranty: • Failure of materials and workmanship • Separation of the UltraGroove Electric/BedLocker/ BedLocker Matte deck panels • Failure of the UltraGroove Electric/BedLocker/BedLocker Matte drive system and electrical components • All hardware and components • Warranty will be prorated after five (5) years

..

Not to worry friend, when my car go sick i avoided going to mechanic looking for DIY_Repair when I found this website https://big-manuals.com/ and this book helped me repair it within an hour, all by myself!!!
From wiring diagrams, schematic illustrations, spark plugs info, parts info, chassis number, valve time settings, step wise instructions, torque specs, error/fault codes, engine info, to every single minute parts, you get everything in there you can't imagine how detailed it is

The best solution you'll get from books at www.reliable-store.com

These are books containing info on repair, service, troubleshooting, parts info, assembling dissemble, removal, error/fault codes, wiring diagrams and everything on any vehicles cars, atv, trucks. forklifts, boats, excavators etc

Diesel or petrol?

I read on another forum where they had a problem with some of their Brake Mechanisms failing.
"Easy fix. Just take 3 screws out from the side of the motor and the unit comes right off. The brake is added so that the bedlocker stays locked in-place once the pressure sensor shuts off the motor. Without it, the cover may activate with vibration of the moving vehicle."
You could also contact Pace Edwards at
http://www.pace-edwards.com/site/?d=123&dt=36
& see what help they could offer.

Toyota Land Cruiser Fuel Filter Replacement PowerModz com

Do you mean DEADLOCKER.

Biggest problem that I have found with these motors concerning idle is a dirty throttle body plate. Get some carb cleaner open the butterfly, spray it grab a rag and clean out as much of the black residue you can. Don't spray to much Down intake. May backfire. You can spray the rag down and work it back and forth. Hope this helps

The remote and unit lost sync when you replaced the battery. Check your owner's manual for steps to resync the two.

As you may be aware, the knob has to be rotated to pull in the latches so you can open the top. When you pull on the strap to close the top, I releases the latches so they will stop at the 1 ft intervals.

1. Make sure that when you pull on the strap, you see the knob pop back to the lock position (handle going side to side) If it stays in a front to back orientation, the strap is not pulling on the latch release.
2. On either side of the roll top, there is a plastic block that keeps the latch bars in place. If one of the screws falls out, you will lose control of the latch on that side so it no longer locks the cover at any of the intervals.

I've had a jackrabbit cover for the past 8 years and I've only had a couple little issues related to the latching. The things i indicated are what I found to be the problem at different times.