Sony KP-57WV600 57" Rear Projection HDTV-Ready Television - Page 5 - Answered Questions & Fixed issues
Color doesn't line up
you need to replace both convergence ic's they are located on your D board mounted right on the 2 big heat sinks you should either need STK-392-560 or STK392-510's you can find which one on stamped on the side of your old ic's. you can go to this sight and get them at reasonable prices plus picture installation instructions and free online tech support if you need help. By doing the repair yourself you will save between 4-500.00 for about a 45min repair
http://servicemanuals.vstore.ca/
What's wrong with TV?
how many times does it flash?
i suspect a bad red tube
sony has a recall on the tubes
http://esupport.sony.com/perl/news-item.pl?news_id=24
Green arches and now green flashes
If you see a neon light in the crt board and it lights up is because the green picture tube is arking inside,the light is supposed to do that and is why is there,the only way to correct the problem is by replacing the picture tube and it can be costly sometimes,there is another way but this will not take care of the problem for good,it might go away for a while but it might return,is hard to tell if it might work,what you need to do is lift the set from the ground about 3 inches and drop it,sometimes just by doing it once it works ,other times it takes more than once,do not over do it or something else might break,is an option you dont have to take and you still have the option to replace the tube.Let Us know how it goes or if you need more information.
Sony KP-57WV600
· 7 times, Diagnosis: Horizontal deflection stopped. Possible cause: Q8035, 8038 is shorted. (D board)
Protection screen
i elieve from what ican find the screen is held together the same as a car windshield(black stickyspoge adhesive) you may have to pull off!!.....or there may beaway from inside ...remove black backin off(only top section)look for screws to remove....you may have to remove screws as well as pull off
Sony KP-57WV600 rear projection
sounds like bad CRT, some of these sonys have had defective CRT issues, usually all will come and go sooner or later (all 3 bad), you can pull the speaker grill off(either 2 1/4" screws on bottom or 6 1/4" on back sides) and pull off the Crt box cover (2'X3' piece) and lightly tap the CRT's with tv on, if they flare or get colored streaks in pix they are bad, CALL SONY 800 # and complain, also could adjust G2 (Screen control for color) for short patch. Will need new crts.
Sony KP-57WV600 screen
I had the same problem except blue lines then all blue..I needed a blue crt tube..........so I'm assuming you will need a green crt tube
How to remove crt tube
I would not advise you to do any service to your tv if you are not experienced. there is high voltage in there and there is alignment procedures to do after installing the tube. It is best to order the original service manual they have a step by step replacement guides in them.
Tv protection screen
if you remove backing you can reach in and up if your small enuff and clean without taking it off but if you want to take i suggest getting another pair of hands or 2 and while their holding screen you take off screws directly behind screen
HD Picture fades and goes balck
u and i both need blue crt tube.i also need convergence fix...u probably will as well .just had repairman over and tubes will be hard to find ...unreal tv is only 4 yrs old /03
Speaker panel
The panel just pulls forward to expose the inner CRT cover. If youy have the faint blue lines that appear especially when there is an absence of video on the screen, the adjusting of the blue CRT control is a VERY temporary fix. It indicates the blue CRT is shorting out internally and that the red and green might not be too far behind. The bad news is 2 of the 3 CRT's are no longer available.
Sony Projection flashes Green once in a while
You have a bad picture tube, no way to sugar coat this one, Sony had issues with all 3 tubes in your model set, more bad news, that green tube is "no longer available" from Sony, tried to order one about 2 months ago for a customer of mine, only the red tube is still available. Sorry to be the bearer of bad news.
Not finding what you are looking for?