20 Most Recent Barrecrafters /sportrack, Sx-12 Ski/snowboard Rack - Page 3 Questions & Answers

indicates a broken wire at the steering head and any movement is breaking contact

Check the switch and if that is ok then check the solenoid

More than likely to is the bearings on the front drive that are out, that would be why the track came loose in the first place.

Clutches can be easily disassembled using the proper puller and spider removal tool, you will also need a holding fixture as the spider can be very tight.

You will get engine specs from the engine tag serial number does not provide this.

Check the diaphragms in the fuel pump most likely flooding through the engine pulse tube from the crankcase.

Valve is bent, stuck open. Pull the heads.

Before you do any of that check exhaust for restriction.

Stator behind the flywheel, using service manual test stator output.

Sounds like fuel supply, most likely bad diaphragm in fuel pump. Start by making sure gas free flows from tank to filter, I would replace filter as it gets overlooked then it should go to fuel pump then carbs. Good luck!

Most likely floats are stuck and carburetors need cleaned.

these will take you up to 1999. http://www.trailz.net/pub/skidoo/Ski-Doo%201999/1999/Mmr_v2A/11_01a.pdf

more than likely you agitated the fuel and now whatever contaminants were in the bottom are mixed in, probably water.

A good mechanic can do anything, it may not be exact fit. You will need the electronic box from the 86 classic and possibly the wiring.

Looks like 89

You pull the complete engine mount baseplate out flip the engine upside down and unscrew the bolts that attach baseplate to engine.

Clean fuel supply, change filter. Clean carbs... Rebuild fuel pump possibly. If this is all good and you haven't done any clutch work it may be time to repair primary and secondary.

It uses an engine stutter system and actually runs backwards when it's engaged. It won't go in if rpm's are too high. How high does it idle?

when the lever is in line with the fuel lines facing across the lines is--- off