Does anyone have a Vaccum hose diagram for a 1995 Kawasaki ZX6R?

This is all I could find in my service documents. Hope this helps.

Did you disconnect the battery? Does it have an immobilizer? It certainly seems to be a known issue!

https://www.google.com/search?q=2005+kawasaki+ninja+zx6r+fuel+light+flashing

..

batt could be slightly weak-maybe at 12.4volts--test it for 12.6 the standard------chec connections---------also carbs cud need pro cleanin and ajust

Hello
The air filter on this bike is under the fuel tank, you will have to remove the seat and there will find the bolt holding the tank down, once this bolt is removed the tank will then just lift up.
Thanks

There are adjustments on carbs for low speed air intake (air mixture screw)find out factory settings and reset that mixture.Sounds to me like those adjustments are out of sink.If so the bike will run very bad from idle to about 1/4 throttle then run great from there up to full throttle.this definitly sounds like carb problem.

It sounds like that hose which runs fron the cap area (inside) the fuel tank to the back bottom is broke, if you take it to a Kawasaki dealer and have your dealer call Kawasaki there is a good chance it will get covered as long as the tank is damaged. Those hoses (metal) that run inside the fuel tak sometimes crack, there is really not way of fixing them unless you cut the tank open and then you would need to reweld it.

it sounds like there is to much oil in the engine the same thing happened to my zx6r, hold the bike upright on level ground then check oil level on the glass viewing window which is on the right hand side of engine, you should see oil level between the low and high marks, if level is above top line you will need to drain some oil out by undoing sump bolt or using a siphon, when ever checking oil level bike needs to be upright on levelish ground some people check oil levels when bike is on side stand which is wrong as it shows oil level as low when in-fact its probably right

Try this manual, it should cover all your needs. Are you sure you have the correct rating fuse in the box, the manual will solve the problem any way. Good luck:

http://vitek.vellum.cz/manualy/Kawasaki%20Ninja%20ZX-6R%2000-02%20Service%20manual.pdf

yes the headlight relay. here is a link to the wiring diagram for your use

http://server6.theimagehosting.com/image.php?img=ZX6r.03.04.GIF&album=24593&fullsize=1