My whole electrical system has failed. I have replaced the battery and all fuses in the fuse panal. I understand that there is a main fuse on the bike. I have looked and think I may have found it. It has writen on it "TL110, 12.8v 85c/m 21WX2+3.4W, 0.7". Is that the main fuse?
No, that is the flasher relay
SOURCE: fuse blowing = total electrical failure
The resetable breaker could be of little amps which cannot take the load of the electricals of your bike, thus its overheating and trips off.
Surprising though it also drains the battery.
There could be some kind of a short in the wiring somewhere.
Why did they replace the main fuse in the first place? Was there any kind of problem to the electricals thn?
SOURCE: 2000 Suzuki 1500 Have problem!
Yeah, you have a short somewhere in the electrical system, or your alternator is overcharging.
SOURCE: Where are the fuses found for the 1500 Intruder?
Ok, there are two places on this bike where you will find fuses. There is a main fuse (30amp) on the starter relay located behind the left upper cover (false fuel tank), and then the main fuse panel is located behind the right rearward engine cover. This cover has only two screws holding it on and they should be hex fittings.
DO NOT try to remove the forward cover (the one with the oil sight glass in it). That is the clutch cover/right side engine cover and is sealed. This cover is held on by regular bolt head bolts.
While your in the fuse box you may want to take note that the oil fill plug is under that first cover as well.
SOURCE: i have an "01" 1500
ur alternator or voltage regulator is probly bad-test it cause the batt is notcharged--1st make sure wiring is good and cables tite--chec fuse panel for any failed ones-use a testlight
901 views
Usually answered in minutes!
×