20 Most Recent
2003 Harley Davidson XL 883 R Sportster - Page 5 Questions & Answers
Gas leak at bottom of tank where fuel gauge wires come out 1998 road king classic
The cup in the fuel tank where the fuel gauge sits has rusted and has pinholes that let the fuel leak where those wires come out. I had the same issue on my 1998 Road King Classic. Take out the fuel gauge and fill the rust holes with jb weld fuel tank repair putty,let it dry ,reinstall fuel gauge. DON'T PUT THE JB WELD ON TOO THICK!!!! It makes it harder to reinstall the fuel gauge.GOOD LUCK
Where is the oil pan plug for a 2005 Harley Davidson 88 evvo
A general rule on any engine is that it will be at the lowest point on the oil pan under the bike. I think on your bike it is on the underside of the pan. To find the bolt find the rear foot peg and move straight downwards. It is usually a hex head bolt with a hex hole in the bolt head for a hex key, (Allen key). I recommend using a socket to remove the bolt as it gives a better grip on the bolt.
Clean the bolt and check the rubber 'O' ring it uses as a seal. If you are in Any doubt about it's condition Replace it anyway! They are usually cheap to buy. Clean the drain hole as well to prevent dirt getting into the oil pan. Once the oil has drained refit the drain plug bolt First, tightening it BY HAND. tighten to around 17 ft/lb. DO NOT over tighten as this will strip the threads on the bolt AND the drain plug hole, (an expensive fix!). Do this Before changing your oil filter and refilling the oil.
The bike needs to be fully upright to do an oil change so make sure it is securely mounted on a bike lift or a pit lane stand.
2000 softail. Why no spark?
You need to make sure kill switch is not OFF! Then a 1, good hot battery. 2 good ignition switch. 3 NEW spark plugs. 4. Good ignition coils. 5. good ignition(source coil, pickup coil,.
Usually takes a professional with the proper tools to diagnose ignition system problems!!
I have a question about my Harley davidson roadking can you help?
Probably. We used to have a Harley Expert named Gregg Mahin. He vanished but he left tens of thousands of helpful posts including manuals, service manuals and videos. Post your question and let's see what we can do. Please make sure you include the year as well, plus a full description of what's wrong and what you have tried..
Install new rear foot pegs
This will depend on the year, model and trim options fitted to the bike. They will be held on in one of 3 ways. A Hex ('Allan Key') bolt, a Torx head bolt or an 'External' Circlip (snap ring). Could you comment below with a photo of both sides of the pin?
You will need a specific tool for each of these.The tools are cheap and easy to get.
The bolts unscrew like any type of bolt. You might need to hunt out the longer Hex and Torx tools. The Circlips need a set of pointed grips you use to ease the clips ends apart to slip it off the pin. The pin should then push all the way through and out the other side of the mount.
2008 road king fuel injection just stopped runnig
If you have a fuel tuner, bypass it to see if the issue resolves. If so, download a fresh map and try it again. If the problem returns call tech support for your fuel tuner manufacturer, it likely needs to be replaced.
Not finding what you are looking for?