20 Most Recent 2004 AJP PR4 125 Supermotard Questions & Answers


check your fuel mix sounds off replace the fuel, plug, and clean ur air filter.

2004 AJP PR4 125... | Answered on Mar 02, 2010


No! Those minerals will break the battery. It has to be distilled water.

2004 AJP PR4 125... | Answered on Nov 10, 2008


Hi, Cliff and the usual suspects are:
1. Ignition Switch not in the "ON" position.
2. Engine Run Switch in the "OFF" position.
3. Discharged battery, check battery terminals for damage or corrosion, check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter if necessary.
4. Bank angle sensor tripped and ignition/light key switch not cycled to the "OFF" position and then back to the "ON" position.
5. Security alarm needs a reset.
6. Starter control circuit, relay, or solenoid faulty.
7. Faulty starter button.
8. Electric starter shaft pinion gear is not engaging or over-running starter clutch slipping.
For more information about your issue, please visit the websites below. Good luck and have nice a day.
AJP motorcycle manuals

Btw, I’m available to help over the phone in case u need at https://www.6ya.com/expert/gregg_c0ec1df182c7330e

AJP Motorcycles | Answered on Oct 29, 2015


Hi, Anonymous and the usual suspects are:
1. Fuel tank empty.
2. Fuel supply valve/petcock turned off.
3. Fouled spark plugs.
4. Engine flooded as a result of overuse of the enricher.
5. Vacuum hose to the fuel supply valve/petcock disconnected, broken, cracked, or pinched.
6. Fuel valve/petcock or filter clogged.
7. Discharged battery, check battery terminals for damage or corrosion, check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter if necessary.
8. Loose or corroded wire connection at the coil, battery or plug between ignition sensor and module.
9. Spark plug cables in bad condition and shorting, cable connections loose, or connected to the wrong cylinders.
10. Ignition timing incorrect due to a faulty ignition coil, ignition module or sensors (MAP, CMP, CKP, O2 and/or BAS).
11. Security alarm needs a reset.
Good luck and have a nice day.

Btw, I’m available to help over the phone in case u need at https://www.6ya.com/expert/gregg_c0ec1df182c7330e

AJP Motorcycles | Answered on Oct 29, 2015


possible the rod maybe overnight, did you get it from new? contact the shop you got it from tell them the problem. shouldn't be a big problem and the bike is new.

AJP Motorcycles | Answered on Apr 05, 2012


Fuel filter dirty? This could be a problem the '85 LTD and the '86 SEI. The fuel filter for those machines are different than the rest. They are for the pressurized fuel system and are a bit expensive. Don't know if mother Honda still has them.

Motorcycles | Answered 3 days ago


We cannot give you diamonds or coins
Please understand that you are talking on a public forum to regular people who offer advice, not to the company that made your singing monster.

Motorcycles | Answered 3 days ago


Hi, Billy you need to repost your question under the Fireplace category, not Motorcycles. Thanks, Gregg

Motorcycles | Answered 3 days ago


USE ENGLISH OUR TRANSLATOR DIED

Motorcycles | Answered 3 days ago


Gap for what .......

Motorcycles | Answered on Nov 30, 2019


Red Dog Shelters is a renowned manufacturer and supplier of portable blast shelters that can deliver you excellent performance each and every time. Their shelters are regarded as some of the best in the industry for their highly secure features.
http://www.reddogshelters.com/portable-protection-shelters.html
towdog-up-undefined-undefined-0.png

Motorcycles | Answered on Nov 30, 2019


Hi, Taylor you need to repost your question under the Generator category, not Motorcycles. Thanks, Gregg

Motorcycles | Answered on Nov 29, 2019


Hi, Anne you need to repost your question under the Thermostat category, not Motorcycles. Thanks, Gregg

Motorcycles | Answered on Nov 29, 2019


Hi, William and the usual suspects are:
1. Spark plugs in bad condition or partially fouled.
2. Spark plug cables in bad condition and leaking check for spark leakage in the dark.
3. Spark plug gap too close or too wide.
4. Faulty ignition coil, module, and or sensor.
5. Battery nearly discharged.
6. Check battery terminals for damage or corrosion, check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter if necessary.
7. Intermittent short circuit due to damaged wire insulation.
8. Dirty air filter
9. Intake air leak.
10. Water, dirt, or rust in the fuel system, fuel pump and/or filter.
11. Old dead or bad fuel.
12. A faulty fuel pressure regulator
13. Pinholes in the in-tank plastic convoluted tubing from the pressure regulator to the quick disconnect check valve.
14. Fuel tank vent system plugged.
15. The throttle body controls misadjusted.
16. Damaged throttle body or intake seals.
17. Clogged or faulty fuel injectors.
18. Loose, dirty, or corroded ignition module connector at crankcase.
19. Faulty TPS, MAP, CKP, O2, and/or CMP sensors.
20. Incorrect valve timing.
21. Weak or broken valve springs.
22. Damaged intake or exhaust valve.
23. The control module may be in limp mode.
24. Check for engine trouble codes.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
https://www.volusiariders.com/60-help/275682-05-c50-running-only-rear-cylinder.html
https://www.youtube.com/watch?v=RvpOq52ud1I
https://www.manualslib.com/manual/1000591/Suzuki-Vl1500.html
https://www.partsfish.com/page/oem-parts-for-suzuki
http://mybikemanuals.com/suzuki/

Motorcycles | Answered on Nov 29, 2019


Check out this post from our resident motorcycle dealer and Fixya expert Gregg Mahin

https://www.fixya.com/motorcycles/t13338238-reset_clock_burgman_650

There is a video here
https://www.youtube.com/watch?v=lwNCvn82c6Q

Motorcycles | Answered on Nov 27, 2019

Not finding what you are looking for?
2004 AJP PR4 125 Supermotard Logo

2 questions posted

Ask a Question

Usually answered in minutes!

Top AJP Experts

Arnie Burke
Arnie Burke

Level 3 Expert

5968 Answers

Marvin
Marvin

Level 3 Expert

85216 Answers

richard libby

Level 2 Expert

209 Answers

Are you an AJP Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

View Most Popular

PR4 125 Supermotard AJP

  • PR4 125 Supermotard AJP

Most Popular Question

ajp 125 r4 supermotard

  • Motorcycles
Loading...