SOURCE: Difficulty to replace EGR valve in 1999 totyota camry 4-cyl automatic
If you have small hands it can be easy. The space between firewall and EGR is tight but it wasn't too difficult to remove. The vacuum hose at the bottom was hard to pull off and I ended up cracking it and had to splice it. It was more difficult to re-install the EGR then remove it. I had a difficult time with keeping the gasket aligned while bolting it in to the lower tube. I took a few attempts. I suggest when replacing the EGR leave the mounting bolts loose so you can more easily align the metal tube. I would tighten the metal tube at the bottom of EGR first then tighten the upper two mounting bolts on top. It took me about 5 minutes to remove and 15 minutes to replace. I would be sure to clean the IAC too after cleaning the EGR. I sprayed throttle bottle cleaner down the bottom hole located on the throttle body and let soak about 15 minutes then start and run the engine a minute and repeat the process. This helped smooth the idle while stopped at a light. It also stopped the idle from shaking and almost stalling the car out at a traffic stop when the engine was warm.
SOURCE: How to remove ignition cylinder from Toyota Camry 1993
Here are step-by-step instructions for the removal and re-installation of your ignition cylinder on your Toyota. Hope this sheds some light on the subject and solves your problem. Have a great day!
CAUTIONSome
models covered by this guidemay be equipped with a Supplemental
Restraint System (SRS), which uses an air bag. Whenever working near
any of the SRS components, such as the impact sensors, the air bag
module, steering column and instrument panel, disable the SRS, as
described in .
On some vehicles, it may be necessary to remove the steering wheel and combination switch first.
To install:
SOURCE: 1999 toyota camry
Take it to autozone and have them to pull a code on it.It sounds like O-2 sincer
SOURCE: 1992 Toyota Camry Rough Idle
start by pulling hose off egr valve see if idles smoother almost instantly
SOURCE: need to find location of egr sensor
A 2000 Camry with a 4cyl does not have a EGR sensor. The ECU uses the readings from the MAP and AF sensors to determine if the EGR is working.
You have a EGR VSV (vacuum switching valve) and a EGR modulator but no position sensor. Only the V6 has this.
Transmission
gear assembly and transmission needs inspection. Also check the transmission
fluid level. Also is the fluid getting leaked or its low.
There
are few very helpful links with solutions to troubleshoot this problem.
========
I
suggest you to refer these links.
Click
the link below:-----
2000 Toyota Camry: Transmission slipping and Stuck up?
http://whatisbyme.blogspot.in/2012/05/2000-toyota-camry-transmission-slipping.html
-----------
Transmission Slips out of 2nd gear?
http://repairhelpcenter.blogspot.in/2012/02/transmission-slips-out-of-2nd-gear.html
----------
Car engine Overheats and transmission starts slipping?
http://schematicsdiagram.blogspot.com/2011/12/car-engine-overheats-and-transmission.html
-------------
2006 Ford Explorer: Engine Vibrates and gears slipping?
http://whatisbyme.blogspot.in/2012/06/2006ford-explorer-engine-vibrates-and.html
---------------
Clutch slipping problem?
http://howtobyme.blogspot.in/2012/03/clutch-slipping-problem.html
----------
Dodge Anti slip System is not operating?
http://whatisbyme.blogspot.in/2012/07/dodge-anti-slip-system-is-not-operating.html
----------
OD light flashing and transmission fluid leaking?
http://repairhelpcenter.blogspot.in/2012/02/od-light-flashing-and-transmission.html
------------
Transmission fluid leaks near radiator on ford windstar?
http://repairhelpcenter.blogspot.in/2012/02/transmission-fluid-leaks-near-radiator.html
-------------
Ford Windstar transmission fluid leaking?
http://technoanswers.blogspot.in/2012/02/ford-windstar-transmission-fluid.html
-----------
TRANSMISSION REPLACING AND
TROUBLESHOOTING
http://alltypesofpartsreplacing.blogspot.com/2012/12/transmission-replacing-and.html
---------
These
details will help.
Thanks.
http://repairhelpcenter.blogspot.in/2012/02/od-light-flashing-and-transmission.html
------------
Transmission fluid leaks near radiator on ford windstar?
http://repairhelpcenter.blogspot.in/2012/02/transmission-fluid-leaks-near-radiator.html
-------------
Ford Windstar transmission fluid leaking?
http://technoanswers.blogspot.in/2012/02/ford-windstar-transmission-fluid.html
-----------
These details will help.
Thanks.
Transmission
gear assembly and transmission needs inspection. Also check the transmission
fluid level. Also is the fluid getting leaked or its low.
There
are few very helpful links with solutions to troubleshoot these problem.
========
I
suggest you to refer these links.
Click
the link below:-----
2000 Toyota Camry:
Transmission slipping and Stuck up?
http://whatisbyme.blogspot.in/2012/05/2000-toyota-camry-transmission-slipping.html
-----------
Transmission Slips out of 2nd gear?
http://repairhelpcenter.blogspot.in/2012/02/transmission-slips-out-of-2nd-gear.html
----------
Car engine Overheats and
transmission starts slipping?
http://schematicsdiagram.blogspot.com/2011/12/car-engine-overheats-and-transmission.html
-------------
2006 Ford Explorer: Engine
Vibrates and gears slipping?
http://whatisbyme.blogspot.in/2012/06/2006ford-explorer-engine-vibrates-and.html
---------------
Clutch slipping problem?
http://howtobyme.blogspot.in/2012/03/clutch-slipping-problem.html
----------
Dodge Anti slip System is
not operating?
http://whatisbyme.blogspot.in/2012/07/dodge-anti-slip-system-is-not-operating.html
----------
OD light flashing and transmission fluid
leaking?
http://repairhelpcenter.blogspot.in/2012/02/od-light-flashing-and-transmission.html
------------
Transmission fluid leaks near radiator on ford
windstar?
http://repairhelpcenter.blogspot.in/2012/02/transmission-fluid-leaks-near-radiator.html
-------------
Ford Windstar transmission fluid leaking?
http://technoanswers.blogspot.in/2012/02/ford-windstar-transmission-fluid.html
-----------
These
details will help.
Thanks.
165 views
Usually answered in minutes!
×