Diagram of 2004 3800 v-6 thermostat - 2004 Chevrolet Impala

http://j.gs/694045/thermostat-video-tutorial

Hello. Here a non-photo diagram. Hope this helps!!!

The thermostat is located on the side of the water pump, the water pump is located just above the a/c compressor, the thermostat is fed coolant from the radiators lower radiator hose.
Thermostat :
1. drain coolant and tighten drain plug ( easier method : remove radiator cap, get big drain pan, place drain pan under lower radiator hose to radiator connection, remove clamp, slowly remove hose, allow coolant to drain into pan, now is a good time to remove radiator hose and clamp from thermostat housing )
2. remove thermostat cover / cap ( easiest to get at this when front of car is supported by jack stands and right hand side lower cover is removed ).
3. thermostat cap is held on by 3 bolts / remove thermostat.

You will notice that the thermostat's air bleed hole is pointing up and lines up with notch in water pump housing,,

ATTENTION :failure to install new thermostat in the correct location will cause engine to overheat.

1. install new thermostat to water pump, make sure air bleed hole lines up with notch, install and tighten bolts, install a new lower radiator hose, fill cooling system.

thermostat # 17670-77E00
lower radiator hose #17854-65G20
hose clamp #09401-36403
upper radiator hose # 17852-65G20

Suzuki factory manual

I seriously doubt if you will find the diagram that you are asking for. The thermostat is very easy on most vehicles. Simply follow the upper radiator hose to where it connects to the engine. This would be the thermostat housing. The thermostat hosing is held on by 2 bolts. Remove the 2 bolts and remove the thermostat housing. The thermostat will be under the housing. Pull the old thermostst out and clean the gasket surfaces on both the engine and the thermostat housing. install the new thermostat and thermostat housing gasket and reinstall ithe thermostat and bolts. On some of the Dodge vehicles it is necessary to remove the alternator and/or power steering pump/ A/C compressor brackets to access the thermostat housing bolts.

there are no diagrams for the location of the thermostat, just follow the top radiator hose to the motor and there will be a metal housing that the hose is clamped to thats the thermostat housing.

• Location for the 3.5 engine

• Larger version of diagram above here http://minus.com/lb0PXktTm0E36L

Location for the 2.5 engine

• Here is a much larger view of the diagram above http://minus.com/lCClBBv2jJ9Es

• Hope this helps.

Could not fine cooling system diagram, but if you follow the upper radiator hose from radiator to engine, where it connects to engine, on that housing, thermostat will be under it, remove small bolt's the thermostat will be under it.

2002 Chevrolet Cavalier 2.2L SFI OHV 4cyl

2.2L VIN 4



Fig. Remove the thermostat outlet bolts and outlet



Fig. Remove the thermostat


2.2L VIN F


Fig. Remove the thermostat


Hope helps (remember rated this)

Top rad hose opistie rad end to motor is thermostat end.Diagram should be under hood rad cowl area look close.

Hi there,

Please see below exploded diagram regarding location of thermostat and water pump.







Regards,
Jeep Brainy

where is the thermostat on the 1999 mazda 626 i need a diagram... the book shows me a different motor....