Tip & How-To about Lincoln Town Car
Early 90's Lincoln town cars have rear air bag suspension and are very prone to failure. cost of one air bag is well close to 250 dollars.
this is a inexpensive fix for that issue. it is possible to install coil spring in replace of the air bags. you will lose the air ride but the cost will be under 100 dollars for both compared to 500 dollars for air ride replacement bags.
the coils that fit are the same year grand marque ford/mercury cars. so when ordering you order for same year as you car grand marque rear springs,
after market or even dealer cost under 100 dollars. they come will the spring seat as the set.
the repair is raise vehicle and support with jack stands. disconnect the lower shock mount so that it allows the rear axle to travel down. this will need to be done for the instillation of the new replacement springs.
next you will need to disconnect the air lines that go to each air back and pull the clips holding the top of the air bag into the chassis of the car. the bottoms float free so this is all that holds them in the car.
remove the air bags out of vehicle and tie air line up and away out of the travel of the car.
install the new spring seats on the rear axle and upper chassis mount.
install the spring top first. you may need to have an assistant pull down on that side of the rear axle to get enough clearness to get the bottom in the seat. you may also try jacking up the opposite side so the side you are working on travels down easier.
after both sides are in there upper and lower seated position.
jack up on the rear axle to install the lower shock mounts back in there original position. after done lower vehicle and recheck all seats to insure they are properly seated. if so you have completed the repair.
this will take no more that two hours start to finish. if you are familiar with a car it may take even less time.
1,442 views
Usually answered in minutes!
×