Speedometer works but odometer &trip don't replaced cluster with one from junk yard no luck Whats not working

If the speedometer still works, you'll probably have to replace the cluster. Chances are a gear broke inside the odometer.

this sounds like a bad speedometer cluster, you stated everything else works so i assume the speedometer is working and just the odometer and trip stopped working and so the speedometer will need replacing. good day.

If your 95 XR7 odometer stopped working the most common problem is the plastic gears. They get so hot the surface shows bubbles that weaken the gears and eventually cause the gear or gears to break and the odometer stops working. The odometer part of the speedodometer has a small electric motor which drives a 16 tooth cam gear also called carrier gear (POD) which then drives a 20 tooth internediate gear which drives the odometer and trip odometer. These 2 gears need to be replaced. I also have a 95 XR7 and had the same problem and I got the replacement gears and did it myself. If you go to www.odometergears.com they have picture instructions and you can also order your replacement gears.

• By Loralye LewisMar 01, 2012
  
  
  • 0 Solutions

your best bet is to replace the whole speed o cluster ,i would start calling your local junk yards or try ebay,you should be able to get one for around 40-60 bucks.

Hello... You normally can"t just replace a bulb on the odometer. You have to replace the whole instrument panel. You might be able to find one at a junk yard...

Good Luck...

IF YOUR SPEEDO IS WORKING THEN YOUR VSS IS OKAY, BAD VSS WILL STOP SPEEDO AND USALLY CAUSE HARD SHIFTING. NORMALLY ODO IS CONTROLLED BY SERVO MOTOR WHICH MAY HAVE WENT OUT. CHECK EBAY FOR REPAIR SERVICES OR SIMPLY GET A SALVAGE CLUSTER AND HAVE MILEAGE RESET

If the speedometer is working but not the odometer it's in the speedometer it's self. replacing the speedometer cluster is the easiest their available on ebay or your local salvage yard.
what happens is the trip odometer wears and sticks, theres a small motor on a circuit board with a plastic sun gear, inside the speedometer housing. it drives both the odometer and the trip odo
the teeth strip off the sun gear and odometer stops.

Problem is in the guage cluster assy.The ODO is mechanical,serviced by replacing guage cluster.

it isnt easy!,the whole unit is peened,and factory assembled,it's built to be non-servicable,get another unit from a junk yard,I have fixed many,and it's a LOT of work!!. in your case it may be simple as replacing the "drive shaft"(it has a worm gear on it).
good luck!!

Check the speed sensor in the transmission.
Being a 95 it might still be cable driven. Disconnect the cable from the transmission and hook a drill to it. Spin it and see if it registers. If it does, the gear going into the tranny is broken, if it doesn't the cable is probably broken.