1994 Dodge Caravan driver's door window won't go up. Pushing the switch to go down works so there is power to the switch and motor, but it won't go up. Need to know how to remove door trim to complete switch troubleshooting. Thanks.
Start by removing the plastic insert at the door handle. This can be pried out with a screw driver, remove the door handle, prior out the plastic tabs, remove the screws there will be approximately four or five screws, lift the panel up and pull awar from the door. Remove the door regulator, you do this by using a punch and pundh out the rivets, then you drill out the aluminum holding in the glass using 1/4 inch drill bit, remove the door regulator and check for damage, you also need to remove the door motor and take it apart. The door motor will have three plastic plugs in the motor remove these, you can purchase new plugs at any auto store for $8.51, howevwer I would recommend you replace with ball bearings which can be purchased for $.64 cents each at any hardware store, pack the motor with wheel bearing grease and replace. You will need 1/4 inch bolts and lock washweer and nuts to replace the door regulator. Normally the switch will not be the problem. I would recommend you replace all the door regulators and rebuild all the motors. If one is going bad the others will follow. Expect to take allday to complete the job. Door regulators can be purchased on line for around $18 to 30 dollars. Good luck.
212 views
Usually answered in minutes!
×