SOURCE: Problem for Volvo 2002 S60 Volvo s60 instrument
Check your fuses. Usually just a $5.00 fix =)
Any black fuses or fuses that rattle are not good.
SOURCE: Can I put a used instrument cluster in my 2002 Volvo S60 2.4t and make it work?
Yes just make sure it's out of the same year and the plug ins match up in the back.
Testimonial: "Thank you. The one im trying is out of a 2001 but the part numbers are the same and the plug in is identical but all I get out of it is a check engine light. It works fine if I put it back in the car it came out of."
SOURCE: Problem for Volvo 2002 S60 Volvo s60 instrument
I have had this problem for about 2 months. I took my whole cluster to an electronics repair shop and asked them to re-solder the entire board inside the cluster. Afterwards, the problem was still there but I noticed that when I put a little bit of pressure on the heatsink, the whole cluster would come back on. So I took it back to the same shop and they made a shim to mount over the heatsink and so far there are no problems and its been 2 weeks.
SOURCE: wrong odometer reading after instrument panel replacement s60
it will automatically read the highest mileage of the two dashes
SOURCE: Can I use a 2001 Volvo S60 2.4T Instrument Cluster in an identical 2002 model year?
I had the same problem on my 2003 V70 with 138K miles. It is an easy fix. Simply remove your DIM by pulling the steering wheel all the way out and down (make sure you remove the key for all the next steps), remove trim around the cluster by pulling gently from the top and once the clips release, pull out the bottom. Next remove the top of the cover directly behind the steering wheel. Once you get those pieces off you will see (4) torx 25 screws on the four corners of the speedo. Remove screws and gently pull top of speedo towards you. Unplug the green connector on the top center of the speedo. I sent my speedo to Powls Speedo repair in Lancaster, PA. There are others such as BBA reman. Powls can either repair your speedo or as happened in my case, I had to get a "donor" speedo from eBay for $75. It was an 2002 S70 and I had it sent directly to Powls. They transfered the mileage info/programming stuff over to the "donor" speedo an sent both back to me. I went to the dealership and had them reprogram in my "donor" speedo uisng vadis. Install opposite of removal. Total costs with shipping, donor speedo and programming was just over $300. Good Luck!!
306 views
Usually answered in minutes!
×