Fisher minute man2 plow. 2005 GMC sierra 2500HD. 2 questions: when all connected, left headlight is on at the truck, right is on at the plow. Also, the 15 amp fuse in the plow harness blows when I

SOURCE: 2005 GMC Sierra Overheating

If your sure there is no trapped air in system after refill and air bleed off, is fan clutch pulling good air thru radiator? Even if it is, the heater should have coolant as hot as what temp gage is showing! Try backwards flushing heater core (dex cool is notorious for plugging these up). There is a TSB for cracked cylinder heads from GM for unexplained coolant loss.Remove drivers side valve cover, and look at center three head bolts for coolant around them, if coolant has been getting in thru this suspect area, there will be a milky/pudding like goo under valve cover and on head. GM had a company called Castec cast these and the areas near the head bolts were found to be too porous (NO recall YET!) Ya, you guessed it, replace heads! Unfortunately, if its gotten hot to many times, it has probably hurt the heads/gaskets. Hope this helps. PS: The castec logo is under the rearmost pair of rocker arms,may have to remove them to see.

SOURCE: ac is blowing warm air in my 2005 sierra 2500hd duramax. Any idea

Your system has R-134 Freon in it. the 134 is made up of smaller molecules than the old R-12. The R -134 permeates through the rubber parts of the system. If the system gets too low on Freon, the compressor will stop coming on.(low pressure cut out switch). Have the system serviced with an A.C. machine that can vacuum, measure the amount of Freon in the system, and add the right amount. The machine can also inject die. Later the die will show up under a black light.This will show any leaks you may have.

SOURCE: 2005 gmc sierra 2500hd heated seat turns off

you have a couple of problems first of all your drivers sd=ide heated heat pad is probably faulty, for your heating problem you may have to get the hvac doors recalibrated.

SOURCE: 2005 GMC Sierra 1500 - heater blows, but only cold air

Check coolant level. Check for heat at the heater hose going from water pump to heater core at firewall. Check to see that cable is moving coolant control valve from the closed to open position. Low mileage so it shouldn't be plugged heater core.

Testimonial: "You were absolutely correct. Low coolant level. Put in some 50/50 and we're nice and toasty now, but need to find out why coolant was so low. Thanks."

SOURCE: special wiring harness for new stereo in 2005 sierra

Yes u do....I have an 03 sierra and apparently they changed everything in 03.....the harness is over $100.....but u need it....and they dont sell a reg wiring kit from 03 and up....if it was an 02, then yes u could get away cheap......it has to do with the steering wheel switches