SOURCE: Where is the drain valve on 2002 dodge caravan radiator?
its a pitcock facing the cab bottom of the radiator, plastic flat. once you find the pitcock just put a bucket underneath and turn it.then refill. if you want to flush(run fluid thru to clean it out) the radiator id suggest taking it in. you dont have to flush it every time you change the coolant out.
SOURCE: Starter installation 2002 Grand caravan
1) disconnect battery cables and push them out of the way
2) underneath the van unbolt (13mm) large cable assembly from starter
3) push red clip forward on small starter connection and push in on clip to remove (sometimes these clips are a pain to get to release)
4) still underneath the van locate and remove bottom starter bolt (15mm) - the bolt is on the transmission side of the engine near the front motor mount bracket, the large wire assembly in front of the transmission sometimes hides it)
5) now you can work up top of the engine - located a stud above where you removed the bottom starter bolt. It will have two wires attached to it. I think the bolt size is a 13mm. Remove the two wires.
6) This stud is really a long starter bolt. If follow the stud to the engine block you will discover it has a 15mm nut on it. You will need a deep 15mm socket and extension to get this bolt out. Mine was really tight! I ended up removing the battery tray and loosening the coolant tank to get enough leverage.
7) Now you can go underneath and pull the starter towards the passenger side. I had to move a few wires to the side and tilt it to snake it out.
8) Installation is just a reversal of removal.
SOURCE: Dodge 2002 Grand Caravan V6 3.3 engine overheating/no cabin heat.
Replace the bad radiator hose first. Second- get you special formulated anti-freeze dye from the auto store and pour it into the radiator. Third- make sure you got all the air pockets out of your system, cause the coolant system won't work with air pockets in it. Fourth- Check for leaks by looking for the colored dye. If it's not the radiator hose, then could possibly be a pin hole in your radiator. Would suggest replacing all the radiator hoses at the same time while you got the coolant system disconnected, cause you don't want to have to come back and replace another hose in a few months.
Testimonial: "Helpful & quick feedback! Thanks! "
SOURCE: 2002 dodge grand caravan fuse box
The fuse box is located under the hood. There is component map printed on the inside of the cover. This tells you on your model where the fuse or relay is located
SOURCE: I am trying to remove my radiator and place it
Chrysler Caravan/Voyager/Town and Country 1996-1999
Radiator - REMOVAL & INSTALLATION
Fig. 1: Before removing the hood latch, mark it's location on the crossmember with a paint marker or other tool
CAUTION
Do not remove the radiator cap or drain with the cooling system
hot and under pressure or serious personal injury can occur from hot
pressurized coolant.
Fig. 4: ... and the upper radiator-to-crossmember bolts, then ...
Fig. 5: ... unbolt the crossmember ...
Fig. 6: ... and lift it from the front of the vehicle
To install:
Fig. 11: Unbolt the lower radiator mounting brackets
Fig. 12: Once all of the components are removed or set aside, the radiator can be removed from the vehicle
Hope help with this, remember comment and rated this.
107 views
Usually answered in minutes!
×