2.5 engine is the fuel pump in the gas tank or somewhere else?
SOURCE: 1988 suzuki samurai
I just ran into this problem as I was rebuilding my 1.3 engine. When you put the mechanical pump back on, you have to be sure the rod that pushes against the pump is all the way in, check this with your finger, you should only feel about 1/4 inch of the rod, if you should feel more, turn the crank with a wrench until it goes in all the way. Then put your pump on making sure that you start both mounting bolts before you begin to tighten, as you tighten gently pull back on the top of the pump, so the lever will line up with the pumps push rod in the head. Your pump will work fine after that.
SOURCE: 89 Suzuki samurai fuel issue
sounds like the electric fuel pump is failing the backfire is a result of a really lean fuel mixture, it is hard to say if u did any damage, most likely not because the pump is inside a anti-slosh baffle
SOURCE: Suzuki Aerio 2004 fuel pump
Hi there ..... You have to drop the tank to access the fuel pump on your vehicle.
SOURCE: Where do I add transmission fluid for my 1999
You'll have two dip sticks under your hood on the engine. One will be for oil the other for tansmission fluid. You can tell you have the transmission because the fluid is a bright redish color where as the oil should be clearish or black, Denpending on your last oil change. The dip sticks are usually on opisit sides or the engine from eachother but could be on the same side. To check your transmission fluid then you need the emergency brake on and the car in neutral and the motor running. On the dip stick there is notches or tiny lines telling you how much is in it. Here;s a very important point to remember. Transmissipon fluid is checked and measured by pints unlike the oil dip stick which is in quarts. So the marks on the dip stick for the tranny will be one pint per mark. To add transmission fluid they sell a skinny long tube funnel that goes directly into the stem that holds the dip stick. You must shut the engine off to add the fluid and restart it in neutral to recheck it. I hope I have been of some service to you and please be kind with your thumbs up for me. good Luck, Raz
Testimonial: "Thanx Raz. I forgot that tranny fluid was measured in pints & that levels had 2 b checked w/ the engine run'g. RJ Sauve, Cameron, NC"
SOURCE: How to change the fuel filter on a suzuki grand Vitara
Fuel FIlter - Removal
To install:
Negative battery cable
Fuel lines from the fuel filter
Fuel filter
Fuel filter and tighten the bracket bolt. Note the fuel flow
directional arrow.
Fuel lines to the fuel filter.
Negative battery cable
To install:
Negative battery cable
Fuel lines from the fuel filter
Fuel filter
Fuel filter is incorporated in fuel pump assembly in fuel tank.
Fuel filter and tighten the bracket bolt. Note the fuel flow
directional arrow.
Fuel lines to the fuel filter.
Negative battery cable
Hope this help.
115 views
Usually answered in minutes!
×