Where do i locate radiator cooling fan relays and breaker.

Replace the fan relays. The Radiator Cooling Fan Motor Relay is located: Under hood, driver side, front side of strut tower, mounted in relay panel
Application:
High speed The Radiator Cooling Fan Motor Relay is located: Under hood, driver side, front side of strut tower, mounted in relay panel
Application:
Low speed,here's a new part.
http://www.autozone.com/cooling-heating-and-climate-control/relay-radiator-cooling-fan-motor/duralast-relay-radiator-cooling-fan-motor/plymouth/voyager-2wd/1996/6-cylinders-3-3-0l-mfi/412240_0_0

Hi Naomi , there is a lot involved in the control of the cooling fans on your vehicle ! There are three fuse's , three relays an a fan control unit !
1. radiator fan main relay , located in underhood relay box A
2.condenser fan relay , located in underhood relay box A
3.radiator fan relay , located in underhood relay box C
4.Cooling fan fuse # 47 20amp. underhood fuse / relay box
5.condenser fan fuse # 50 20amp in underhood fuse / relay box.
Any one of these could cause them to not work, rather then just replacing parts an wasting money you should take it to the repair shop !

It can be faulty fan relay.The relay is not turning the system off.Or its wire short issue.Even with ignition off ,the fan relay is getting power so its not letting the fan to turn off.Bypass the fan control relay and see if still the fan works with ignition off or not.

For more troubleshooting check the link below:------

Cooling Fan Stays ON with Ignition Off?

http://whatisbyme.blogspot.in/2012/07/cooling-fan-stays-on-with-ignition-off.html
--------------

Cooling fan relays location ?

http://technoanswers.blogspot.in/2012/02/cooling-fan-relays-location-on-1998.html
------------

DIC says "COOLING FAN FAULT"?

http://schematicsdiagram.blogspot.com/2011/12/dic-says-cooling-fan-fault.html
----------

Heater fan and headlights will not turn off with ignition off?

http://technoanswers.blogspot.com/2012/01/heater-fan-and-headlights-will-not-turn.html

-----------

Fuel pump relay and cooling fan relay troubleshooting ?

http://repairhelpcenter.blogspot.com/2011/10/fuel-pump-relay-and-cooling-fan-relay.html

-------------

Where Is Radiator Fan relay and Fuse Located?

http://schematicsdiagram.blogspot.com/2011/12/where-is-radiator-fan-relay-and-fuse.html

------------
These will help.
Thanks.

If the fan not turning on when car engine getting hot,then car will notice overheating.Click this link below for troubleshooting:---http://technoanswers.blogspot.in/2012/02/car-running-hot.html--------To know how engine cooling system works ,click the link below :----Engine cooling components working?

http://repairhelpcenter.blogspot.com/2011/11/engine-cooling-components-working.html

------------------
How does Vehicles Engine cooling system works? http://repairhelpcenter.blogspot.com/2011/11/how-does-vehicles-engine-cooling-system.html
------------How to Replace Engine cooling Fan:-- http://repairhelpcenter.blogspot.com/2011/11/how-to-replace-engine-cooling-fan-on.html
-----------Replace Fan Relay but still Radiator cooling fans not working? http://schematicsdiagram.blogspot.com/2011/12/replace-fan-relay-but-still-radiator.html
----------DIC says "COOLING FAN FAULT"? http://schematicsdiagram.blogspot.com/2011/12/dic-says-cooling-fan-fault.html
---------Where Is Radiator Fan relay and Fuse Located?

http://schematicsdiagram.blogspot.com/2011/12/where-is-radiator-fan-relay-and-fuse.html

--------

This will help.

Thanks.

For radiator replacement procedure and radiator problem troubleshooting. I suggest you to click the link below and follow the detailed procedure :-----

------------

How to Replace Engine cooling Fan on car? http://repairhelpcenter.blogspot.com/2011/11/how-to-replace-engine-cooling-fan-on.html

------------

Engine makes noise and Cooling Fan belt Breaks? http://howtobyme.blogspot.com/2011/12/engine-makes-noise-and-cooling-fan-belt.html

-----------

Replace Fan Relay but still Radiator cooling fans not working? http://schematicsdiagram.blogspot.com/2011/12/replace-fan-relay-but-still-radiator.html

--------

Cooling fan relays location? http://technoanswers.blogspot.in/2012/02/cooling-fan-relays-location-on-1998.html----------DIC says "COOLING FAN FAULT"? http://schematicsdiagram.blogspot.com/2011/12/dic-says-cooling-fan-fault.html
------------

How to replace radiator Cooling Fan?

http://repairhelpcenter.blogspot.com/2011/11/how-to-replace-cooling-fan-on-acura-car.html

---------------
Engine cooling components working?

http://repairhelpcenter.blogspot.com/2011/11/engine-cooling-components-working.html

-------------
How does Vehicles Engine cooling system works? http://repairhelpcenter.blogspot.com/2011/11/how-does-vehicles-engine-cooling-system.html

----------

cooling fan not working http://schematicsdiagram.blogspot.in/2012/02/hyundai-sonata-cooling-fan-not-working.html----------- Fuel pump relay and cooling fan relay troubleshooting? http://repairhelpcenter.blogspot.com/2011/10/fuel-pump-relay-and-cooling-fan-relay.html

----------
Why Transmission fluid leaks near radiator?

http://repairhelpcenter.blogspot.in/2012/02/transmission-fluid-leaks-near-radiator.html

----------
Transmission fluid leaking?

http://technoanswers.blogspot.in/2012/02/ford-windstar-transmission-fluid.html

-------------
How to replace Radiator?

http://repairhelpcenter.blogspot.com/2011/11/how-to-replace-radiator-on-audi-and-vw.html

----------
HOW TO REPLACE AN UPPER RADIATOR HOSE

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-upper-radiator-hose.html

------------
HOW TO REPLACE A LOWER RADIATOR HOSE

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-lower-radiator-hose.html

-------------
How to replace Radiator on Car models?

http://repairhelpcenter.blogspot.com/2011/11/how-to-replace-radiator-on-acura-car.html

------------
How to flush cars radiator?

http://repairhelpcenter.blogspot.com/2011/11/how-to-flush-cars-radiator.html

--------
HOW TO PRESSURE TEST A RADIATOR AND CAP

http://schematicsdiagram.blogspot.com/2011/07/how-to-pressure-test-radiator-and-cap.html

----------------
HOW TO REPLACE A RADIATOR

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-radiator.html
------------------

HOW TO REPLACE A RADIATOR SUPPORT

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-radiator-support.html

-----------

This details will help.

Thanks.

Turn vehicle off. Allow to cool. Raise hood.
Try to see if the fans spin freely by hand. If not, replace. If they do spin, proceed to next step.
Next step-
Check coolant level, add if needed. Remember-radiator must be cool before opening cap. Make sure radiator cap is secure and tight if coolant was added.
Start vehicle. Observe coolant gauge as vehicle warms. Fans should come on when temp gauge reads halfway between c and h.
If fans do not come on see if they come on when you turn on ac or heat. If doing this makes them come on, suspect faulty cooling fan sensor switch. If they don't come on replace cooling fan sensor switch and fan relay.

Fan relay is located under pass headlight. Remove light assembly, use 2 1/2 " hole saw to drill hole in plastic housing ,3"from back wall, 3'' from left side.This will put you right over relay. Unscrew two bolts,replace. Relay was $40.... dealer wanted$350 to remove front bumper to replace it.

the fan relays are inside the main engine compartment junction box. and the fan "switch" is a function the the engine computer. it looks at engine speed vehicle speed and coolant temperature to decide whether to turn the fans on or not. I doubt its the ecu, most likely the fan relays.just pull them out and put new ones in.

I don't thing there is a short there is radiator fan switch that control these fan, it works off of heat. There is also a fan relay that control look in fuse box inside the hood for fan relay and make sure its NOT stuck , if it isn't then its the fan switch.This switch may be bad and cause the fan to turn on. Replace radiator fan switch located on water outlet on engine and this should solve your problem. A

Dodge Caravan is notorious for failure of the electronic cooling fan control module (AKA cooling fan relay). This is not a "relay", it is a solid-state control unit, but many people call it a relay anyway.
It is mounted on the inside of the left frame rail just behind the radiator. You have to look up from UNDER the vehicle to see it. It looks like the picture below. The picture shown is very close to actual size.