Heat blower motor stopped

The most common thing is to listen it would require several tests to fix but first was the blower motor making any noise at all when on? if so replace the blower. if it was a window then when you moved the switch then it blew problem in window motor or wire see it takes a lot of time and effert to trace a short but try this first you might get lucky Good Luck Mike L.

blower silent on high or not? test on high
if blower makes load sounds on high it is good
the dampers are failing,

WELL THE USERS GUIDE IN THE GLOVE BOX TELLS WHERE ALL FUSES ARE LOCATED. (LOST IT) IT IS FREE "GOOGLED"
FREE IN usa NO COUNTRY TOLD
we check all fuses, first. never skip this a 25 cent fuse bad.
most cars made have 2 fuses boxes, 1 cab , 1 bay(engine)
or even 4 on huge SUV or even more 9 passenger vans. see?
all cars are unique. and not the same for all engines and countries.
no engine told.
the free guide is at (amazing no?) toyota
all pages.
https://www.toyota.com/owners/resources/warranty-owners-manuals.rav4.1996

they split up the chapters, 7-1 is fuses

page 169

https://assets.sia.toyota.com/publications/en/om/OM42420U/pdf/omsource/1996om/96rav4om/sect8/81.pdf


fuse #11,eng.bay
fuse 21 , cab box

the books was in the glove box day 1 new car, sure lost it.

blower dead on high.
USA car is 1996
is fuse 7 and 8 ( 8 is link box) <<,tricky that.
and heater relay
if 12vdc makes it to blower motor 2 pins the blower is dead, we use voltmeter to that or hot wire the motor too. 2 tests.
usa dwg

This is most often caused by a failed blower motor, the brushes are worn out or sticking and not making good contact to the armature of the motor, one other possible cause is a defective blower motor switch and or connector

there is a TSB for a noisy blower motor and not working except on Hi, both cover under 36K miles, repair includes replacing blower motor and or resistor block and harness, judging your problem can be a bad resistor block and harness. hope it helps

You need to replace the blower motor resistor.

Check blower motor unit for ice build up. If all clear your blower motor needs replacing. I would recommend a service shop to do diagnoses.

its probably in a seperate fuse box under the hood

Well the blower motor is underneath the dash on the passenger footwell, you have to remove the glove compartment to gainaccess to the blower, it ahas 3 or 4 bolts holding the motor, remove and replace with new unit, it is a good idea to replace the filter once the motor is removed.

check blowere motor resistor on or next to motor on passanger side

if the fan does'nt come on at any speed have the fan checked if fan is good check the switch if on good replace fan switch located inside there is also a regulator under dash behind the glove box if the fuse's,motor & switch are all good this regulator the last comp. in the heater circut or you have a broken wire. hope this is helpful