SOURCE: 4 wheel drive
on the right side of differential there's an axle tube that goes to the right side half shaft, the 4wd actuator is on top of that tube, i believe in 93 it is still freon charged so it can go away slowly and when it is cold, just unplug the wire and unscrew, you can update to an electric actuator, but on some models you need to grind the axle tube a little
SOURCE: 1995 2500 silverado front axle 4x4
from 88 to 98 everything mechanical was the same. the only difference was the vortecs in the late 90's
SOURCE: 1996 suburban makes grinding noise in 2 wheel drive
sounds like the clip on the rear output shaft its probably broke. do this by removing the rear driveshaft, and the tail of the transfer case, there are 4 bolts holding it in place. then grab the output shaft and see if it has any front to back movement. if so pull it all the way to the rear and you should see a groove at the front part of the shaft where the clip goes. Then you should find the pieces fo the clip in the tail housing. One person said he found the replacement clip at a local tranny shop. I am calling the dealership parts counter for a new clip for my 97 Tahoe tomorrow. Hope this helps..
SOURCE: 2004 silverado 4x4 2500 left front wheel bearing
To install:
Tire and wheel assembly
Caliper and rotor
Wheel speed sensor and brake hose mounting bracket bolt from the steering knuckle
Electrical connection for the wheel speed sensor
Front drive halfshaft assembly on four wheel drive models
Hub and bearing assembly mounting bolts
Hub and bearing assembly
O-ring seal from the steering knuckle bore (2500 series)
You can go to autozone.com and register for free online repair manual with everything you need.
Hub and bearing assembly
Hub and bearing assembly mounting bolts. Tighten the bolts to 133 ft. lbs. (180 Nm).
Front drive halfshaft assembly on four wheel drive models
Electrical connection for the wheel speed sensor
Wheel speed sensor and brake hose mounting bracket bolt to the steering knuckle. Tighten to 106 inch lbs. (12 Nm).
Rotor
Tire and wheel assembly.
On
these issue, there are few solved help links for troubleshooting the
issue easily.-------
Click
the link below: ---
http://repairhelpcenter.blogspot.com/2011/12/no-4x4-light-on-dash.html
-----------
http://schematicsdiagram.blogspot.com/2012/01/4x4-truck-makes-roaring-noise-in-front.html
-------------
http://schematicsdiagram.blogspot.com/2011/12/car-will-not-go-into-4wd-high-or-4wd.html
--------------
http://repairhelpcenter.blogspot.com/2011/12/no-4x4-light-on-dash.html
------------
http://technoanswers.blogspot.com/2012/01/4-wheel-drive-system-will-not-disengage.html
----------
http://schematicsdiagram.blogspot.in/2012/02/4wd-light-is-flashing-and-beeping-no.html
----------
http://technoanswers.blogspot.in/2012/06/2002-jeep-wrangler-4wd-idiot-light-is.html
----------
Traction
control switch will not engage on 4WD High or Low
http://whoisbyme.blogspot.com/2012/10/traction-control-switch-will-not-engage.html
-----------
4WD light
flashing and 4WD will engage after few minutes
http://repairhelpcenter.blogspot.com/2012/10/4wd-light-flashing-and-4wd-will-engage.html
------------
http://technoanswers.blogspot.in/2012/05/2008-toyota-tundra-4x4-wheel-drive.html
----------
http://technoanswers.blogspot.in/2012/02/4x4-front-differential-will-not-engage.html
-------
-------------
http://technoanswers.blogspot.in/2012/09/dodge-ram-4x4-light-keeps-flashing.html
----------
http://technoanswers.blogspot.in/2012/02/ford-4x4-front-wheels-will-not-engage.html
-------------
These
details will help.
Thanks.
On
these issue, there are few solved help links for troubleshooting the
issue easily.-------
Click
the link below: ---
http://repairhelpcenter.blogspot.com/2011/12/no-4x4-light-on-dash.html
-----------
http://schematicsdiagram.blogspot.com/2012/01/4x4-truck-makes-roaring-noise-in-front.html
-------------
http://schematicsdiagram.blogspot.com/2011/12/car-will-not-go-into-4wd-high-or-4wd.html
--------------
http://repairhelpcenter.blogspot.com/2011/12/no-4x4-light-on-dash.html
------------
http://technoanswers.blogspot.com/2012/01/4-wheel-drive-system-will-not-disengage.html
----------
http://schematicsdiagram.blogspot.in/2012/02/4wd-light-is-flashing-and-beeping-no.html
----------
http://technoanswers.blogspot.in/2012/06/2002-jeep-wrangler-4wd-idiot-light-is.html
----------
Traction
control switch will not engage on 4WD High or Low
http://whoisbyme.blogspot.com/2012/10/traction-control-switch-will-not-engage.html
-----------
4WD light
flashing and 4WD will engage after few minutes
http://repairhelpcenter.blogspot.com/2012/10/4wd-light-flashing-and-4wd-will-engage.html
------------
http://technoanswers.blogspot.in/2012/05/2008-toyota-tundra-4x4-wheel-drive.html
----------
http://technoanswers.blogspot.in/2012/02/4x4-front-differential-will-not-engage.html
-------
-------------
http://technoanswers.blogspot.in/2012/09/dodge-ram-4x4-light-keeps-flashing.html
----------
http://technoanswers.blogspot.in/2012/02/ford-4x4-front-wheels-will-not-engage.html
-------------
These
details will help.
Thanks.
4X4
On
these issue, there are few solved help links for troubleshooting the
issue easily.-------
Click
the link below: ---
http://repairhelpcenter.blogspot.com/2011/12/no-4x4-light-on-dash.html
-----------
http://schematicsdiagram.blogspot.com/2012/01/4x4-truck-makes-roaring-noise-in-front.html
-------------
http://schematicsdiagram.blogspot.com/2011/12/car-will-not-go-into-4wd-high-or-4wd.html
--------------
http://repairhelpcenter.blogspot.com/2011/12/no-4x4-light-on-dash.html
------------
http://technoanswers.blogspot.com/2012/01/4-wheel-drive-system-will-not-disengage.html
----------
http://schematicsdiagram.blogspot.in/2012/02/4wd-light-is-flashing-and-beeping-no.html
----------
http://technoanswers.blogspot.in/2012/06/2002-jeep-wrangler-4wd-idiot-light-is.html
----------
Traction
control switch will not engage on 4WD High or Low
http://whoisbyme.blogspot.com/2012/10/traction-control-switch-will-not-engage.html
-----------
4WD light
flashing and 4WD will engage after few minutes
http://repairhelpcenter.blogspot.com/2012/10/4wd-light-flashing-and-4wd-will-engage.html
------------
http://technoanswers.blogspot.in/2012/05/2008-toyota-tundra-4x4-wheel-drive.html
----------
http://technoanswers.blogspot.in/2012/02/4x4-front-differential-will-not-engage.html
-------
-------------
http://technoanswers.blogspot.in/2012/09/dodge-ram-4x4-light-keeps-flashing.html
----------
http://technoanswers.blogspot.in/2012/02/ford-4x4-front-wheels-will-not-engage.html
-------------
These
details will help.
Thanks.
105 views
Usually answered in minutes!
×