Gearbox oil how much oil manual gearbox take

'Transmission Fluid' in a manual transmission vehicle is called 'gearbox oil'. On the gearbox, there is a drain plug in the bottom somewhere and a fill plug on the side. You drain, clean the drain plug, replace the copper washer and put the drain plug back in. Fill the gearbox with oil until the oil starts to weep out of the filling hole. Replace the fill plug.

Google

year make model change gearbox oil

Please include 'year make model' in all questions in this category. Thanks.

Manual gearboxes usually require a gearbox oil change every 30,000 to 50,000 mi (48,000 to 80,000 km). Automatic gearboxes usually have gear oil change intervals of between 60,000 to 100,000 mi (96,000 to 160,000 km). It's advisable that you change your gearbox oil filter at the same time as your oil.
Aug 23, 2019

When and how to check and change your gear oil and filter

..

Manual Transmissions don't have dip sticks.

2. Manual gearboxes have a drain and filler plug. The filler plug is usually found in an accessible position on one side of the gearbox which has to be accessed from under the vehicle.

To top up the gearbox the car has to be perfectly level so if you need to add oil to the gearbox you ideally need to get the car up on a garage hoist/lift so you can both access the filler plug easily, remove it and pump in the fresh gear oil. The usual correct oil level on these gearboxes is level with the bottom section of the filler plug opening in the gearbox. However you should check with the proton service staff on the correct procedure for topping up the manual gearbox in your car.

No but check with the dealer or your service/owner manual for the manufacturer recommended gearbox oil change periods.
There is no filter on the manual gearbox .
Whatever the manufacturer recommended period is for a gearbox oil change, change the gearbox oil twice as frequently as recommended to maintain it in good condition. If, for example, a change every 50000 miles is stipulated then do it every 25000 or so.

There are seals on the front and rear of the transmission. If the clutch wasn't covered in engine oil, then replacing the crankshaft seal wasn't necessary. Reseal the transmission.

gearbox oil grade SX75W/90 make is upto you

oil filler plug on the manual gearbox usually are located on iether side of the gearbox with a square or hexagonal head plug or bolt. Some are Allen head drive.

VW 1.4i with manual gearbox 5 speed transmission:
1. Oil type: VW G50 & G51, full synthetic oil SAE 75 W 90
2. Gearbox refill = 1,9 litres
3. Filling plug location: Side of transmission

I am confused - I have a simple query and logged on to your site as you offered free advice! Do you not offer the service as described on your website. I definitely don't need a team of experts to answer my very simple question.

Regards

Vic Fenn

It would depend on what Transmission u have, Auto or Man
I presume you mean manual when u say gear oil not trans fluid ,

But just in case you can Have a look in the suzuki owners forum for an exact volume of gearbox oil capacity
Visit the Suzuki Car Forums


Try draining it into container to get some idea