20 Most Recent 2004 Kia Sedona Questions & Answers


Kia Sedona expansion FRONT valve located under dash, behind glove box, fan and coil. Evacuate freon first. Disconnect Freon lines from firewall., Lay right front seat back to flat horizontal position and lay on top or totally remove the seat for easier working access. Remove under dash cover, fan, glove box, coil housing, remove coil mounting bolts, remove old expansion valve. (Inspect old valve, if debris inside, blow out coil before installing new valve. If visible debris best to consider replacing REAR expansion valve and DRIER/FILTER in front of radiator too and blow out all lines and coils while servicing.) Use compressor oil to lubricate "O" rings on new FRONT or REAR expansion valve, install valve bolts, reinstall coil bolts to FRONT firewall or REAR frame, reconnect freon lines to firewall in engine compartment. Evacuate AC system, install freon (35 1/2 ounces, nominal 3 pounds), check system for leaks, check for proper operation, enjoy.

2004 Kia Sedona | Answered on Apr 23, 2019


1 key must be turned on.
2 brake pedal needs to be applied
if the keys on and your pushing the brake pedal wiggle the steering left to right. have a great day.

2004 Kia Sedona | Answered on Apr 19, 2019


If manual, could be rust. Carefully spray some WD-40 in the joint. If electric, then a blown fuse might be cause. See a manual about that. Search on line.

2004 Kia Sedona | Answered on Apr 02, 2019


Good Morning. Here is step by step along with a photo. I hope this helps! Best of Luck.

  1. Install the valve covers and tighten the bolts in sequence to 43 inch lbs. (5 Nm).
  2. Install the valve covers.
  3. Install the ignition coils.
  4. Install the cables from the spark plugs.
  5. Install the intake manifold.
  6. Install the vacuum hose, fuel hose and coolant hose.
  7. Install the breather hose and air-intake hose.
  8. Connect the upper radiator hose.
  9. Connect the negative battery cable.
  10. Fill the cooling system.

0996b43f80207113-isvorejxmkopi3ttjbxpjnz0-2-0.gif

2004 Kia Sedona | Answered on Mar 30, 2019


https://www.fixdapp.com/blog/p0306
https://www.fixdapp.com/blog/p0300
https://www.fixdapp.com/blog/p0304

2004 Kia Sedona | Answered on Jan 14, 2019


You will get your solution and all info on service info, repair info, parts info, wiring/electrical/fuse diagrams, error/fault codes, torque specs, PCV,
owner's/service/repair/parts/maintenance manuals etc everything
this website www.reliable-store.com
it's a very good website for vehicle problems even as old as 1991 ford..

2004 Kia Sedona | Answered on Mar 19, 2018


I know this website www.reliable-store.com that i
get manuals from, and they have all models online that solve all simple/technical problems like professionals

I also brought for my 1989 BMW, such old model, they had it and it was very good manual. Go ahead, I bet.

2004 Kia Sedona | Answered on Mar 14, 2018


some times you need to unbolt motor mounts and lift motor to remove

2004 Kia Sedona | Answered on Feb 02, 2018


Try getting the error code by using a plug in diagnostic unit, the code should give you a good starting point, but in any case you should be able to clear the error code with the unit after you make a not of it and maybe with it being intermittent it might not reappear. But heck out what the code is before clearing. the diagnostic units are available quite cheaply on auction sites.

2004 Kia Sedona | Answered on Jan 18, 2018


The gas smell may be from filling the gas tank too much. When filling tank, do not over fill tank. when the fuel nozzle clicks off the first time do not add more fuel. It will back fill into the emission evaporator canister and therefor smell like gas fumes until the fuel tank get's lower. on a hill the gas in the tank may flow into the opening of the evaporation canister. I have had this happen and thought it was a leaking fuel line. Don't over fill Fuel Tank...

2004 Kia Sedona | Answered on Jan 07, 2018


could be spindle the boss will wear out when the bearing gets worn out just replaced one on the drivers side got from salvage yard whole thing

2004 Kia Sedona | Answered on Jan 06, 2018


If you radiator is full ,as in you have no leaks, it is most likely going to be a water pump issue. Unless you have a serious clog in the system, but chances are its the water pump, not an uncommon thing to go wrong

2004 Kia Sedona | Answered on Dec 21, 2017


Those are your only codes? you really shouldnt have drilled out your cats, its hard to diag an 02 sensor online. a scanner could show if they are functioning properly. It might be an issue with your cats though and require replacement.

2004 Kia Sedona | Answered on Dec 21, 2017


Why do you think you have an air leak in the system? whats the issue? typically if there is a leak its gas coming out not air going in. Are you low on fuel pressure or something? is your fuel pump weak? fuel filter clogging?

2004 Kia Sedona | Answered on Dec 21, 2017

Not finding what you are looking for?
2004 Kia Sedona Logo

1,513 questions posted

Ask a Question

Usually answered in minutes!

Popular Products

2003 Kia Sedona
2003 Kia Sedona

1,041 Questions

2002 Kia Sedona
2002 Kia Sedona

1,018 Questions

2005 Kia Sedona
2005 Kia Sedona

693 Questions

2006 Kia Sedona
2006 Kia Sedona

452 Questions

Top Kia Experts

Colin Stickland
Colin Stickland

Level 3 Expert

22485 Answers

Marvin
Marvin

Level 3 Expert

85216 Answers

Jonah Oneal

Level 3 Expert

14092 Answers

Are you a Kia Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

View Most Popular

Sedona Kia

  • Sedona Kia

Most Popular Question

kia sedona 2004 2 9 diesel 116000 miles

  • Cars & Trucks
Loading...