Hyundai Motor 2002 Sonata - Answered Questions & Fixed issues
Problems fillng the gas tank 2002 Sonata
i just went through that problem
Evap canister / close solenoid and air filter $211- 230.00 in parts
$675- $71.00 at dealships for this small 30 minute task
If no check engine light Evap canister and air filter - fixxes problem 100 %
note:you may be able to get by just replacing air filter- works
rarely
if have check engine- close solenoid and purge solenoid may need replace- you local autozone- like autozone will pull check codes for free
the how to:
Jack car up in rear - behind right rear tire - canister -canister close solenoid & air filter are located in a plastic box with metal strap and one bolt.
Unscrew bolt everything drops down the EVAP CANISTER is held to plastic box by wirer tie . Remove wire tie and solenoid connection.
There is a small metal wire clip the holds the solenoid electrical connection together with a flat screw driver pry up the wire clip , off is okay too , ....it will go back on.
Once you have done all that you have full access there are i believe from memory 3 rubber hoses with clips ......Mark hose connects very important mark the hoses way the going on evap canister with color tape .
Next, remove whole assembly- the solenoid and air filter will come with the evap canister.
Now that have the whole assembly move to your work bench
look to see how the soleniod hook up to the canister and the air filter - now, disconnect the hose to black solenoid and remove the air filter which hook to solenoid and solenoid at same to ......
Next seperate the the solenoid and air filter- you should be air to put your mouth on solenoid and blew air in one hole and out the other- this solenoid is noramlly open- if air dosen't go threw is stuck closed and must be replaced.
same with air filter- this air filter are know for get plugged and should be replaced every 30,000 miles.
Also note: over fill you gas tank , at fill up - can cause the Evap to get liquid gas inside which cause the chorcoal in the filter to swell up and plyug the system up.------ you should when fill up stop pump gas after the auto pump click off on normal work tank and not try to top off you tank.
note: check with your deal for exact wieghts
weigh the evap canister - six pound - replace it- new one is about 4-4.5 pounds - it is just best to replace .The evap holds gas fumes then send to engine so that dosn't vent to
All parts are dealships only -
This is easy fix and normal, for gas fill problems
canister Evap 161.00
canister close solenoid 43.00 may or may not be used
air filter 7.00
not used in this fix- check engine fix use these parts
sensor price ?
purge valve 39.00
canister close solenoid 43.00
7/25/2019 1:16:10 AM •
Hyundai Motor...
•
Answered
on Jul 25, 2019
•
4,316 views
Replaced battery now there is zero juice
Don't assume that a new battery is ok. Personally, I've fitted a new battery to later discover that it was that new battery at fault.
However, it's quite rare ..
If your battery is discharging very quickly irrespective of whether the engine is running or the car is parked - suspect the alternator. Inside the alternator there is a rectifier pack - diodes - if this fails it can allow your battery to discharge very quickly - sometimes within a minute or two, quite literally.
If you can, disconnect the leads from the back of your alternator and charge your battery. Reconnect the battery but not the alternator. If your car starts and continues to start without the battery going flat - your alternator is at fault.
The only other fault that can cause a healthy battery to discharge is a parasitic drain - something is remaining 'live' after the engine is switched off and draining your battery power.
If you drive your car to a spares shop/auto electrician they will be able to tell you within a minute if your alternator is the problem.
What is the distance between the throttle and MAF
hi, you should buy a service manual of the product if you are getting the problem with your product from the reliable store which will help you in solving your problem
here's the link
http://www.reliable-store.com/products/2002-hyundai-sonata-workshop-repair-service-manual-pdf-download
How do I remove and replace the trunk lock on my Sonata
hi, for that you need an operator manual for your product which you can get it from the reliable store and here's the link from where you can buy it.
http://www.reliable-store.com/products/2002-hyundai-sonata-workshop-repair-service-manual-pdf-download
2002 hyundai sonata lx will not shift gears automatically but will manually
Huyndai's are netorious for transmissions doing funny things if the Throttle Possition Sensor is bad. Not an expensive part that you could probably change yourself. It is an inexpensive try, if it does not remedy the situation. Also, the computers regulate shift patterns. You might unhook the battery and leave it unhooked for 30 min. or so, and see if it will re-learn shift points.
How to replae the fuel tank in detail for sonata 2002
raise and support the rear of vehicle, then disconnect all fuel, vacuum lines, electrical wires that go to the fuel tank. disconnect the fuel filler neck from gas tank, support the fuel tank with a jack, disconnect the fuel tank support straps and lower tank looking for anything that you may have overlooked to disconnect.
2002hyumdai sonata door lock button on door
Do you have electronic door locks? If so, check your fuses-simplest place to start. Next I would take the lock out on the inside, it could be a bad ground wire. Good Luck.
Windshield washer pump comes on
it might not have some windshield fluid...add some water in the reservoir for the windshield and see if that works...
Good Luck!
Engine wont turn over
Having had this problem (a couple of times on our 2002 Hyundai Sonata GLS V6) my first guess is, its probably the starter. So although there are other possibilities, I would be surprised if it's not. The first time I replaced it with a used starter from a salvage store. That turned out to be a mistake because I had to replace that one within a year. Replacing the starter isn't too hard, depending on your mechanical skill level. The quick sequence is; disconnect the battery. Remove electrical connections from starter. Remove mounting bolts (3 I think). Maneuver the starter down and out (this is a little tricky). If you choose to do this and need more detailed info let me know. I would also suggest you get one that carries a limited lifetime warranty because our Sonata may actually be on its fourth starter (I'd have to look at the records). Good luck.
Not finding what you are looking for?