2005 Volvo S40 T5 - Answered Questions & Fixed issues


Possible water pump failure. Was temp guage showing "hot" ? , if not maybe coolant sensor issue. Had the car just been driven hard ? Any pressure in coolant expansion tank ?

2005 Volvo S40... | Answered on Jun 30, 2019 | 25 views


Check vacuum leaks and fuel injection system

2005 Volvo S40... | Answered on Dec 18, 2016 | 452 views


Have it scanned and check the Fuel pressure.

2005 Volvo S40... | Answered on Oct 23, 2015 | 56 views


need to have your tranny rebuilt.

2005 Volvo S40... | Answered on Apr 17, 2014 | 176 views


du a tune up--change or clean distributer cap--and plug wires------fuel filter nmay be dirty or pump cud hav issues--battery gettn old and not holdn 12.6volts

2005 Volvo S40... | Answered on Oct 26, 2013 | 99 views


Hello
The Engine and Automatic Transmission (not applicable to manual transmissions) in this vehicles drive train are fully electronically controlled by a computer called the PCM and TCM (Power Train Control Module, Transmission Control Module). When a problem like this or other drive-ability related problems occurs the computer stores a record of the problem (there are of course some exceptions to this, like the fuel pump, engine coolant temperature sensor and MAF sensor for instance) in the form of a fault code in its memory, to read these fault codes you must have the systems memory scanned with a special tool. Once the fault code(s) are read you then must perform the appropriate diagnostic testing to find and resolve the problem(s) DO NOT REPLACE ANY PARTS UNTIL A TRAINED TECHNICAIN HAS DIAGNOSED THE PROBLEM TO AVOID SPENDING YOUR HARD EARNED MONEY ON PARTS THAT MAY NOT CORRECT THE PROBLEM. Also always check fuel pressure for correct spec for your make and engine type.

2005 Volvo S40... | Answered on Sep 04, 2012 | 228 views


Car not starting or turning over indicates towards multiple possibilities. It can be issue with battery or weak battery. But if battery checks out ok, then it can be starter issue or faulty alternator or problem with low fuel pressure or no spark at spark plugs due to dirty spark plugs or faulty ignition coil or injectors getting cracked or dirty and needs to be cleaned.


To confirm the problem, the basic troubleshooting is required.


Click this link below and follow the troubleshooting:------

http://technoanswers.blogspot.in/2012/02/car-starting-issues.html

---------

This will help.

Thanks.

2005 Volvo S40... | Answered on Mar 03, 2012 | 568 views


ECM 400 are evap codes

2005 Volvo S40... | Answered on Feb 22, 2012 | 121 views


You may have an old engine oil, why don't you have your car service and change oil and oil filter as well. Then if the problem still appears, then that's the time to start tracing where the problem really starts.

Volvo S40 Cars &... | Answered on Dec 28, 2018 | 43 views


Do you have anymore information. If so please forward everything you have regarding this problem. If the car is starting, running but not accelerating there may be a problem with the accelerator pedal position sensor or related circuit. Usually the engine light will turn on because the EMC identified a fault and a code or codes will be stored. If the engine light is on or flashing please have the codes read. Any questions please write back. Good Luck.

Volvo S40 Cars &... | Answered on Oct 31, 2018 | 27 views


The easy and cheapest fix is to get a new key cut and tape the head of the original key in close proximity to the halo ring sensor.

Volvo S40 Cars &... | Answered on Oct 24, 2018 | 34 views


Sounds like you got motor oil in your coolant. What does the motor oil look like on the dipstick? If it's the same milky, muddy color and thick, you need to have some major work done. Either a head gasket or cracked head or block.
If the motor oil looks OK, you need to drain, flush/clean, and refill your cooling system with fresh coolant. I would strongly recommend having an experienced mechanic check it out for you.

Volvo S40 Cars &... | Answered on Jul 04, 2018 | 55 views


I recently tried the DIY service and repair manuals from a website and it actually helped me repair transmission problem in my jcb 3cx site-master. it wont move forward or reverse, engine is good both solenoids for forward and reverse work.
I don't have much technical knowledge but I just followed it step-wise, and works perfect! got it from www.reliable-store.com
All the best

Volvo S40 Cars &... | Answered on Mar 22, 2018 | 38 views


Blue smoke is often the result of bad rings on the pistons. Engine rebuild time. It is possible that the turbo is leaking oil into your engine.

Volvo S40 Cars &... | Answered on Feb 19, 2018 | 100 views


take it to a power steering specialist shop and have them check the drive belt first and the the power steering for failure

Volvo S40 Cars &... | Answered on Feb 16, 2018 | 65 views


google this there are some answers on line which may help you and some videos .

Volvo S40 Cars &... | Answered on Jan 20, 2018 | 54 views


Did you test all the parts befor fitting ? Faulty parts would need to be replaced , have you wired the lights independently ? If so it shouldn't affect the CCM.

Volvo S40 Cars &... | Answered on Dec 05, 2017 | 132 views

Not finding what you are looking for?
2005 Volvo S40 T5 Logo

Popular Tags

22 questions posted

Ask a Question

Usually answered in minutes!

Popular Products

2000 Volvo S40
2000 Volvo S40

665 Questions

2001 Volvo S40
2001 Volvo S40

488 Questions

2005 Volvo S40
2005 Volvo S40

319 Questions

2006 Volvo S40
2006 Volvo S40

169 Questions

2004 Volvo S40
2004 Volvo S40

152 Questions

Top Volvo Experts

Marvin
Marvin

Level 3 Expert

85222 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22485 Answers

Jonah Oneal

Level 3 Expert

14092 Answers

Are you a Volvo Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...