20 Most Recent Polaris 2005 Magnum 330 4X4 Questions & Answers

check engine oil level

its more than likely under the seat... If you need further help, reach me via phone at https://www.6ya.com/expert/allen_b068623c5003aa4b

Have you checked the fuse terminals coming off the battery there is a fuse some times it is a bad ground make sure battery is charged

Have the ignition module unit tested, I had one go bad and it did the same thing. Eric

If I remember right it does the little black box (not the CDI box) the 330 I replaced the control box on once i replaced the box the speedo did light up again been along time ago but I think if you repalce the control box it will fix your problem

Some of the Polaris have magnetic locking hubs there is a little black box up in front if I remember right it has three wires coming out of it I think two yellow and one red this unit controls the front hubs I bypassed this control one time by running a low voltage 12 volt supply to the front hubs used a toggle switch to activate the 4wd when needed it was a old farm bike and the guy did not want to spend the money to replace the control box

If the shocks are worn out, get off the machine and lift up on the back rack. This takes up the slop between the shifter box and the transmission, and usually allows me to shift. I also had an issue with the thin steel plate behind the shifter box. Got a crack in the top , so it was flexing, creating more slop. Welded it shut, good as new.

isnt that a 2 stroke? go to polaris for an owners manual

Sounds like a bad regulator.

what?? it just bolts on??

don't worry about it if everything works properly!

interesting problem