Questions & Answers for: Chevrolet Silverado 1500HD transfer case clunking

transfer case of 2002 silverado 5.3 I know I have a leak in the axles causing me to add fluid to the transfer case. Where is the filler? You have to crawl under the truck, and on the rear cover of the

...transfer case. It is a common problem with your truck. The transfer case is a np236. If it just recently started doing this, the rebuild will cost around $800. If the 4wd has been acting up for a ...

shaft clunks ina car). No clunking sound in 4wd or 2wd. Do you have locking hubs or just the auto button inside the cab? It isnt you transfer case it sounds like it could be your front axle or bearing

vehicle will move in 4 wheel drive not in 2 wheel just bangs and acks like locked upin 4 wheel loud banging sound with each revalution Sorry, It sounds like transfer case failure.

...transfer case motor engages front drive shaft, front diferential actuator extends, but no 4 wheel drive. What do I check next? There may be vacuum lines running down to the hubs. If so check them for ...

2003 chevy 1500 hd 4x4 dash says [ service 4wd] i did not no i had a problem . what could it be? The light usually is a factory schedule maintainence (transfer case fluid) $75 at firestone

...transfer case to look for, i dont know what modle my transmission is and transfer case is, i have a 2002 chevrolet silverado 1500HD please getback to me asap !!!! The transfer case has a label on it ...

transfer case stuck in 4wd Your encoder motor is broken or your front diff actuator is stuck try checking your fuses then pull your actuator is it working? Shift it in 4 wheel while parked listen for ...

...transfer case, it might be hub not releasing.  This last one can be checked by putting vehicle in 4H, then with transmission in neutral, back to 2H, and then back the truck in a straight line ...

transfer case installed by dealer approx. 3 weeks ago. truck has just turned 200k. 2002 1500hd Crewcab 4x4 6.0 gas. i would seriously inspect the neutral safety switch connector located on the side of