Questions & Answers for: Plymouth Voyager remove tank

Neighbor has a 1999 Plymouth Voyager Explorer that has gas leaking in the rear of the vehicle. does the tank have to be dropped to repair the line and or clip at the fuel pump? Thanks you will only ...

...TANK SLIGHTLY TO REMOVE LINES FROM FUEL PUMP UNIT..1 BOLT HOLDS IT TO TANK..2 CONNECTIONS AT TANK..1 AT LINE ON FRAME IN FRONT OF TANK Different locations have been used on these vans for the fuel ...

...Remove the fuel pump and its O-ring from the fuel tank, and discard the old O-ring. 5. Cover tank openings to prevent dirt from entering system. FUEL GAUGE SENDING UNIT REMOVAL 1. Gently bend the ...

...remove the gas tank, (if you can) run the van near empty. The tank is located on the passenger side. Start by Placing the van on jack stands, remove the battery ground, and you'll need to remove all ...

...tank so that you can remove the lock ring for the fuel pump. This will allow you to remove the fuel pump. Step 5 Install the new fuel pump using the items included in the kit. Use a torque wrench to ...

tank to remove any loose dirt. Using special tool No. 6856 or equivalent, remove the fuel pump locknut by turning it counterclockwise. Remove the fuel pump and O-ring from the tank. Discard the O-ring

...remove bolts on tank straps completely, make sure you remove all lines and hoses from sending unit on top. Once your sure all are removed, place a floor jack or similar under tank, and use a piece of ...

...tank, and remove straps, to lower tank, and it's in the tank.(from top) Try to get fuel level as low as possible, or empty, and have something, or someone under there to help support tank when ready ...

tank. Remove the ground strap, the inboard side fuel tank straps and the front T-strap fastener, then lower the tank approximately six inches. 3 Take the fuel lines from the fuel pump module. Plug the

...remove your tank to gain access The fuel hose(s) go to the same place so simply trace the fuel hoses back to the tank. Some vehicles have an access panel in the floor of the van so check for this. To ...