Question about 1 Hp, 4 Gal. Air Compressor
...lies between the head and the upper reed plate and has only a 1/4 inch strip of material between the intake and output reed valve cavities. Periodic retorquing of the head may be
Question about 3 gal. Air Compressor, 1.5 hp, Horizontal k
...valve plate, discharge reed should be on the head side. There should be a divider in the head side to separate the inlet from the discharge. Make sure the valve plate is turned so that the air from ...
Question about 25 gal Air Compressor 3 12 hp Vertical k 2 Stage Oil Free Pump
valve plate /reed valves or worn cylinder /vinyl ring. Easy to check, push piston to top position and examine cylinder neer top looking for scratches. If scratched, most likely vinyl piston ring/s are
Question about 1 hp Air Compressor, 4 gal. - 16638
...reed valve. Before you remove any parts, with compressor running, check all fittings for leaks with soapy water. If no leaks, remove head and examine parts. If reed valve is broken replace as needed ...
Question about 1 hp Air Compressor, 4 gal. - 16638
...pumping up pressure only to 25,bowing out trough air cleaner Sounds to me like bad (or dirty) reed valves. Carbon buildup on the reed valves can cause poor seating of the valves. ...
Question about 3 gal. Air Compressor, 1.5 hp, Horizontal k
...so you'll most likely have to get parts through Sears at www.searspartsdirect.com. For best results replace everything between the head and cylinder; gaskets, valve plates and reed
Question about YT 3000 42" Kohler 22 hp Gas Powered Riding Lawn Tractor
...think some of the pictures here can show the reed valve location and removal at this link http://gardentractorpullingtips.com/images/breather.gif ...
Question about YT 3000 42" Kohler 22 hp Gas Powered Riding Lawn Tractor
...valve plate can be repaired. Usually only one or two reeds break. Carefully trim off broken reed exposing port hole. Tap hole with fine thread and make plug with proper matching bolt. plug should be ...
Question about YT 3000 42" Kohler 22 hp Gas Powered Riding Lawn Tractor
...common problems are failed poppet valves or reed valves broken springs for poppet valves failed non return valve in the pipe to the tank pull the head/s and check the poppet valves or reed ...
Question about YT 3000 42" Kohler 22 hp Gas Powered Riding Lawn Tractor
...What now ? Answer was to replace reed valves. I have replaced the valve head, so this can not be the problem indicates reed/ poppet valve problem possibly a broken spring in a head pressure ...
Usually answered in minutes!
49 Questions
42 Questions
38 Questions