Need glass gasket fro GTI gas 6000GDV serial # 7631

Try on ebay or contact the company for infomation

You will need to remove any metal trim surrounding the glass. It usually just slips/pop off.
Once that is off, the wing nuts and clamps will be exposed. There will probably be quite a few. All of them will need to be removed and set aside. Depending on what type of gasket material the manufacturer used between the glass and the metal firebox, will determine how easy it will be to remove. I hope for your sake, it's a rope gasket. If not, it will have a rubberized high temp gasket material, which may require a thin blade metal putty knife. It will be used to carefully get behind the glass and the rubberized gasket to help it release from the metal around the firebox. try to keep the gasket in one piece. If you can't it will have to be replaced.

Once the glass is loose, carefully lift it up and away from the fireplace. It's best to clean it on a flat surface (counter top, kitchen table, etc) that has a couple of layers of cotton bath towels for padding.

DO NOT use a commercial glass cleaner to clean the glass. As most have ammonia in them. A 50/50 solution of White Vinegar and water works best. Use a clean sponge to wipe the glass with the vinegar and water solution. Paper towels to dry it. Use only as little pressure as need to clean the glass, as you don't want to break it. If the glass has a heavy build up on the inside part of the glass, you can use a plastic mesh scouring pad to get this off. Then wipe again with the vinegar and water solution and dry it.

After everything is cleaned and dry, reinstall the glass in reverse order of how you removed it.

I hope this helped you and thanks for choosing FixYa.

GTI 4 Serial Key: http://sharecash.org/download.php?file=1407339

follow top radiator hose to motor, at motor that should be your thermostat housing, pull 2 bolts out holding it @ remove housing, thermostat is under, replace thermostat exactly as you removed it, you will need a new gasket also.

pull out the bottom drawer you will find a plate on the left side pillar of the drawer opening the model # and, serial # is there this is all that is needed to order a new door glass

I would guess that you could not. It is a safety glass and has a special gasket material. Although you may be able to buy the door as cheap or cheaper than just the glass plus the install. Hope this helps. Have a great day.

Contact your nearest Heat-N-Glo dealer for part #446-511 thermocouple. If you need a thermopile thats part #2103-512. To find your nearest dealer go to www.heatnglo.com

green

I have a 14 year old GTI fireplace the pilot is lite but when i push the button to turn it on , the fire place does not come on help please