Top 20 Kohler Command OHV Horizontal Engine with Electric Start 20 HP, 1 Questions & Answers


pull the carby and clean out the bowl and main jet
check for a blockage in the fuel lines to the carby, including the fine mesh filter in the tank at the tap

Kohler Command... | 45 views | 1 helpful votes


Either badly seated oil rings or PVC valve is stuck open allowing oil to enter through carburetor.

Kohler Command... | 214 views | 0 helpful votes


sounds if no throttle cable is connected and your running it off the govennor to be asking this question ,(if it had a throttle cable increasing it would bring speed up) the govenor speed is adjustable by the little screw on the top of carbarator that is connected to silver half moon (looking clip) use care to not overspeed engine if done while running , and a little bit goes a lot on the screw

Kohler Command... | 66 views | 0 helpful votes


Are there any faults listed on the control display? If display is dark then likely a battery issue. Check battery voltage with a Digital Multi Meter (DMM). It should be at least 12.5VDC.

Kohler... | 58 views | 1 helpful votes


The engine is failing to run after a commanded start. Repeatedly.

Kohler... | 37 views | 0 helpful votes


if you have an scr pack, that has 6 pins, there are two for ac, two for gates, and two for the excitation field.
The two gate wires come off your adc controller.

Kohler... | 73 views | 0 helpful votes


http://www.kohlerpower.com/onlinecatalog/pdf/g2058.pdf
Safety shutdowns:
  1. Loss of coolant
  2. High water temperature
  3. Low oil pressure
Likely one of these. If no indicators at a panel check at the connector.

Kohler... | 71 views | 1 helpful votes


There might be two reasons for the failure of generator auto start.

1. It is the ATS automatic conversion control device that does not issue the start generator command after the mains power failure or phase loss operation, or the self-starting relay failure, which causes the generator to not start itself. This situation is relatively rare.

2. It is the generator start battery failure, and this kind of situation is relatively more.

Kohler... | 130 views | 0 helpful votes


the parts manual is a tp-5317 which I do not have . You said its a dec2? or a fast response 2? What is the part number off the main circuit board in the control box?

Kohler... | 78 views | 0 helpful votes


It should be 130 lbs. or better.
It may be a little lower if it has not run in a while.
Robert

Kohler... | 119 views | 0 helpful votes


get it from a Kohler service agent spares

Kohler... | 56 views | 0 helpful votes


Sounds Like possibly the regulator is the issue.
Flightsystems Can test these to see if it is good or not.
also here is a link for the service manual
https://us.v-cdn.net/5020499/uploads/editor/0c/g1lx13xi2vyy.pdf

Kohler... | 587 views | 0 helpful votes


You need to repair your locked rotor then it will work

Kohler... | 1,248 views | 0 helpful votes


try typing in google might come up with help

Kohler... | 179 views | 0 helpful votes


maybe this what you wanted you , Service Kit Kohler Marine Generator Models 4EF 5E 6EF 7.3E
Maintenance Service Kit Kohler Marine Generator Models 4EF 5E 6EF 7 3E

Kohler... | 95 views | 0 helpful votes


drain the fuel and replace with ethanol free gas

Kohler... | 243 views | 0 helpful votes

Not finding what you are looking for?
Kohler Command OHV Horizontal Engine with Electric Start 20 HP, 1 Logo

5 questions posted

Ask a Question

Usually answered in minutes!

Top Kohler Electrical Supplies Experts

Sheldon Dedek

Level 3 Expert

909 Answers

rjivaro

Level 2 Expert

158 Answers

J. Bradshaw

Level 2 Expert

121 Answers

Are you a Kohler Electrical Supply Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

View Most Popular

Kohler Electrical Supplies

  • Kohler Electrical Supplies

Most Popular Question

engine dies when engaging blades

  • Electrical Supplies
Loading...