20 Most Recent Precor 546 Elliptical - Page 4 Questions & Answers


is the safety key inserted as there may be a connection to not allow the unit to operate unless the key is in position

Precor Exercise... | Answered on Dec 04, 2016


If you wish to get some details about treadmill repair ; check the site linked here. Pull up older posts. http://electro-medical.blogspot.com/

Precor Exercise... | Answered on Nov 13, 2016


If you wiah to get some details about treadmill repair and service then check the following link
http://electro-medical.blogspot.com/

Precor Exercise... | Answered on Oct 03, 2016


If you wish to get some details a bout treadmill repair then check the link bellow.
http://electro-medical.blogspot.com/

Precor Exercise... | Answered on Jul 20, 2016


A noise issue can be anything. I recommend you hire a service technician

877-805-1030
Book An appointment

Precor Exercise... | Answered on Apr 23, 2016


Hi Emily, The safety switch... If that's the plastic part with the steel plate inside it that attaches to the console and when you remove it the treadmill won't operate then try cutting the top off a can and using that until you find the safety switch...Good Luck.....CHEERS..

Precor Exercise... | Answered on Apr 14, 2016


Starting at the outlet, follow power into the machine. If you are getting power past the circuit breaker and in to the power board, chances are your lower board is toast. The only solution is to replace the item with a new or known good used board. The following links will take you to a video on how to use a multimeter to verify power. Video about Multimeter Testing

Precor Exercise... | Answered on Dec 02, 2015


Replacement Parts for Fitness Exercise Equipment at SPORTSMITH

This sounds like you are dealing with a worn deck and belt. If you apply wax periodically, you can prolong the life of these components. Using your serial number, the link below will help you find the deck and belt needed for your model.

Precor Repair Parts for 9 45 9 45i Treadmills Consumer SPORTSMITH net

Precor Exercise... | Answered on Nov 13, 2015


Replacement Parts for Fitness Exercise Equipment at SPORTSMITH

This is normally caused by a stuck key on your keypad. To resolve this issue, you must replace the keypad.

The following link may help, but you will need your serial number to find the correct item.

Repair Parts for Precor C954i Treadmills 120VAC 240VAC SPORTSMITH net

Precor Exercise... | Answered on Nov 13, 2015


Replacement Parts for Fitness Exercise Equipment at SPORTSMITH

Precor Error LS, Speed Sensor Signal Missing Probable Cause 1. Intermittent or open connection of the speed sensor (reed switch) wiring.
2. Reed switch is defective or has intermittent connection.
3. Drive motor brushes are bad.
4. Lower PCA is bad.
Corrective Action
  1. Inspect the speed sensor (reed switch) wiring for damage or poor connection to the lower PCA. Replace damaged wiring or reset connection as necessary.
  2. Using an ohm meter, test the reed switch while rotating the drive pulley. The reed switch will close when the magnet passes in front of it.
  3. Inspect the drive motor brushes and replace if necessary.
  4. Test unit with a known good lower PCA. Replace lower PCA if necessary.

Precor Error Code LS

Precor Exercise... | Answered on Nov 10, 2015


Replacement Parts for Fitness Exercise Equipment at SPORTSMITH

You can find the diagram for this model by using your model and serial number at the following link.

Repair Parts for Precor C954i Treadmills 120VAC 240VAC SPORTSMITH net

Precor Exercise... | Answered on Nov 04, 2015


Replacement Parts for Fitness Exercise Equipment at SPORTSMITH

Typically this is caused by a bad pillow block bearing. I would suggest trying to pin point the sound a bit better, but this is common of the pillow block bearings.


Precor Parts for EFX 554i 556 556i Ellipticals SPORTSMITH net

Precor Exercise... | Answered on Oct 29, 2015

Not finding what you are looking for?
Precor 546 Elliptical Logo

2 questions posted

Ask a Question

Usually answered in minutes!

Top Precor Exercise & Fitness Experts

Jose Pino

Level 3 Expert

563 Answers

Ross Metcalfe
Ross Metcalfe

Level 2 Expert

135 Answers

Tom Chichester

Level 3 Expert

52796 Answers

Are you a Precor Exercise and Fitnes Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

View Most Popular

Precor Exercise & Fitness

  • Precor Exercise & Fitness

Most Popular Question

when turn machine display not come up

  • Exercise & Fitness
Loading...