20 Most Recent ClubRunner Motorized Golf Cart - Page 5 Questions & Answers

Check to see if the carb is gravity fed or has a fuel pump. If it gravity fed then trace the line back to the tank checking for an obstruction. Make sure there is no obstruction in the tank. Flush the tank and lines. If it has a fuel pump, make sure it is working properly. If fuel is at the carb. then you may have to clean the carb and adjust the float.

Try a electronic flasher. Wire power to flasher from light switch. Then wire flasher to lights.

Since 1981 Club Car Golf Carts have positioned their serial numbers just under the glove box on the passengers side of the vehicle. The first two numbers (not letters) indicate the last two digits of the year of manufacture. On Club Car Golf Carts prior to 1981, you can find the serial number by raising the seat and locating the aluminum, I-beam frame section closest to the batteries on the driver's side of the car. If the serial number plate has been removed, you can confirm it is a 1975-1980 model if it has two brake pedals and one accelerator pedal.

Right here: http://www.vintagegolfcartparts.com/yamaha-wiring-diagrams

The engine is stalling due to too much load (torque) when it's on the ground. This most likely means a problem with a clutch or it's gearing.

I DON'T KNOW. CHARGE FULL AND USE A 'LOAD CELL TESTER' TO READ CONDITION. IF OK, LOOK FOR A SHORT IN SYSTEM. CAN'T FIND FAULT ? PAY SOMEONE TO LOCATE SOLUTION. AS AN ALTERNATIVE, INSTALL BATTERY CUT OFF SWITCH TO USE WHEN CART NOT IN USE. IF BATTERIES NOT GOOD, LOOK ON INTERNET FOR IDEAS TO REVIVE.

If you have gas engine it could be converter belt. video below has some maintenance tips and one of them talks about converter belt issues, mainly not having the proper belt. https://www.youtube.com/watch?v=DhNk5U8ofqo If it does use a converter belt It could also have issue with the drive or driven converter. I have had problem with Kawasaki mule driven converter which is the converter the belt rides on for the transmission. https://www.youtube.com/watch?v=SnB_KACRjuw

Spray starter fluid into the carb. If it starts then clean the fuel system.

In the fuse box

Try here https://www.manualslib.com/

Try this site https://www.manualslib.com/

Try here https://www.manualslib.com/