Honda 3000 Watt Portable Generator - Answered Questions & Fixed issues


In the process of using diesel generator set, soft rubber pipe is easy to rub with the parts around it, and it is easy to wear and tear oil leakage in the long run. However, most of the fuel supply system of diesel generator set uses soft rubber tube, so it is not easy to find the oil leakage point. Below are instructions provided by Starlight Power small make up to teach you a few diesel generator unit pipeline leak spot check method.

Method one: exhaust the air from the diesel generator unit, then start the unit to find out the leak point.

Method two: release the gas screw of the unit injection pump and release the oil from the hand oil pump. If it is found that the discharge screw starts to discharge a large amount of bubble oil, and the bubble still does not disappear after the repeated hand pump, it can be determined that there is a leak point in the low pressure oil pipeline from the oil tank to the oil pump section. The pipeline should be removed, pressure gas and placed in water, to find out where the bubble is the leak point.

Honda 3000 Watt ... | Answered on Nov 21, 2018 | 837 views


http://cdn.powerequipment.honda.com/pe/pdf/manuals/31ZT7601.pdf

I would check spark arrester and clean it and the muffler first.lt could be the inverter unit. If you have a meter determine the output voltage, and freq. You would need a scope to look at waveform the repair should be lest to a repair center. suggest you call Honda for more guidance.
You could spend a lot of money on maybe parts./

Honda 3000 Watt ... | Answered on Mar 06, 2018 | 134 views


Hi there dirty plugs or fuel system

Honda 3000 Watt ... | Answered on Mar 06, 2018 | 152 views


Residual magnetism of the rotor out. Lift one brush off the slip rings and flash a 12 volt battery on the rings. Reconnect brushes and start engine no output? Repeat then seek help as I need to put my grippers on it to check

Honda 3000 Watt ... | Answered on Feb 07, 2018 | 164 views


hi
insure the wires from the magneto are not cracked or shaved as this would discharge to earth and the ht lead from the magneto to the plug is not perished as this would create leakage to earth

Honda 3000 Watt ... | Answered on Jan 13, 2018 | 191 views


Try Googling (Honda)(GA-6HZR)(manual) without parens.

Honda 3000 Watt ... | Answered on Nov 25, 2017 | 39 views


Of course you can, just use the correct weight.

Honda 3000 Watt ... | Answered on Nov 16, 2016 | 172 views


Give us a call when you are with the Generator and we will run through it with you. Call your local office and speak to an engineer: http://www.generatorguru.com/ask-the-guru/
Generator Guru

Honda 3000 Watt ... | Answered on Sep 25, 2015 | 60 views


THERE COULD BE SEVERAL CAUSES; THE VOLTAGE REGULATOR, THE CARBURETOR, THE OIL LEVEL. ALL NEED TO BE CHECKED.

Honda 3000 Watt ... | Answered on Jun 18, 2015 | 166 views


No, as with most small equipment engines, the culprit is the carburetor. You'll need to soak it in carb cleaner overnight in a sea;ed container and install the rebuilt kit for it.

Honda 3000 Watt ... | Answered on Jun 16, 2015 | 282 views


how to reset the valves on a honda 3000 generator

Honda 3000 Watt ... | Answered on Dec 13, 2014 | 777 views


Make sure that the exhaust is not clogged.

Honda 3000 Watt ... | Answered on Dec 05, 2014 | 63 views


New battery for Honda eu3000is can be found on amazon. take a look here Charge your devices with guaranteed safety and chose the best one. P.S. watch out on seller reviews. I hope this was helpful. cheers

Honda 3000 Watt ... | Answered on Nov 25, 2014 | 11,716 views


I assume you refer to a 6500 watt Honda, if it's electric start/and manual(pull cord) First supply a 12 volt battery /if you haven't put fresh gas in it do the best you can to remove all the old gas from the tank and you should find drain screws and small hoses on the lower part of the carburetor. After completing this step add about 1 gallon or so of fresh gas, remove the air filter system from the face of the carburetor ,with a small squirt bottle put a tea spoon or so of gas into the of the carb, close the choke and turn the key, if it fires let it run with the choke closed for only a few seconds then slowly open the choke fully, if the engine stalls close the choke and start the engine again do not leave the choke closed for extended periods as this will cause engine flooding and spark plug failure. Also be sure you have inspected the existing spark plug to be sure it's clean if there is any question about the plug change it.

BR

Honda 3000 Watt ... | Answered on Oct 22, 2014 | 191 views


On a honda part, I would check with Honda directly. Their customer relations folks are good to deal with:
Customer Relations
Tel: 770-497-6400
Fax: 678-339-2519
Mon. - Fri. 8:30 - 7:00 EST
I did find that part on EBay for sale. I have to admit, I don't recall seeing that part on a Honda eu3000.

Honda 3000 Watt ... | Answered on Sep 25, 2014 | 92 views


By fire I assume you mean spark at the plug. When turning the engine over with the key and the oil alert light comes on the spark is interrupted by grounding the system thus the engine cannot start.
First, look at the obvious things, check oil level if it is at the recommended level smell the dipstick if it has a strong smell of gas
change the oil and try to start it again. Be sure the plug is not soaked with raw fuel before you try the restart. I the problem persists you can disconnect the wire from the top of the low oil sensor.Try to start the gen. if it starts change the low oil sensor.
I hope this all makes sense to you , good luck with it.

BR

Honda 3000 Watt ... | Answered on Jul 24, 2014 | 122 views


If the plug isn't fouled and looks all right, it could be the resistor cap on the plug wire. It could also be a warning from the CDI that it is giving up the ghost.

Honda 3000 Watt ... | Answered on Jul 07, 2014 | 194 views


This action is called governor hunting which generally means the carburetor needs resetting ,a complete internal cleaning or a rebuild
then adjust the high speed and low speed settings by the adjusting screws on the governor spring system (manual may be required for these settings)

Honda 3000 Watt ... | Answered on Mar 19, 2015 | 385 views


Never heard of an etq Honda generator,if is a Honda generator any Honda dealer should be able to help you. If its a Honda knock off ,some Honda springs will work.

Honda 3000 Watt ... | Answered on Apr 13, 2015 | 109 views

Not finding what you are looking for?
Honda 3000 Watt  Portable Generator Logo

182 questions posted

Ask a Question

Usually answered in minutes!

Top Honda Electrical Supplies Experts

John Trevino

Level 3 Expert

1407 Answers

Norman Al-Anbar

Level 3 Expert

630 Answers

Sheldon Dedek

Level 3 Expert

909 Answers

Are you a Honda Electrical Supply Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...