Question about 2003 kawasaki KLR 250

3 Answers

My 2007 Kawasaki KFX50 starts and idles fine, but after about 10 minutes of riding it acts like its either starving for fuel or floodind out. I have replaced the spark plug, air filter, cleaned the carb, drained and refilled the gas tank with new gas, and even replaced the entire exhast system with new stock exhaust from the local Kawasaki shop, but it still wont run for more than 4-10 minutes. I have to let it set for about a half hour before it will start and run again. Please Help ! Thanks Nate

Posted by on

Ad

3 Answers

  • Level 1:

    An expert who has achieved level 1.

    Corporal:

    An expert that has over 10 points.

    Mayor:

    An expert whose answer got voted for 2 times.

    Problem Solver:

    An expert who has answered 5 questions.

  • Contributor
  • 6 Answers

Unrelated Recall Alert: CLICK ME

Some articles I have read suggest removing the stock auto-choke carb and replacing it with a Honda CT70 Carb. Check with a local shop to verify, I do not own either and am just passing along the info.

Another solution suggested by 'OneRide': Try it with the gas cap off. The tank vent might be plugged. Possibly plugged fuel filter. Are you using the choke correctly?

This seems to be a very common problem and no 'one' solution to fix it.

I hope this helps.

-spaz

www.leeds-pc.com


Posted on Nov 29, 2009

Ad
  • Level 1:

    An expert who has achieved level 1.

    New Friend:

    An expert that has 1 follower.

  • Contributor
  • 1 Answer

Valve adjustments? It’s 2 stroke guys

Posted on Jul 17, 2018

Ad
  • Level 2:

    An expert who has achieved level 2 by getting 100 points

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

    Vice President:

    An expert whose answer got voted for 100 times.

  • Expert
  • 255 Answers

If you've looked at the solutions suggested above and still haven't solved it, you'll have to dive into really analyzing the carburetor (Keihin PTE 16). The most probable cause is float needle problems. Don't neglect to check valve clearances, as you've mentioned that this is a heat-related problem, and valves with too close of a tolerance will cause just these symptoms. (Yes, the valves can most certainly get out-of-spec during run-in, although not probable.) You can check for too-tight valve clearances by the lack of compression on start. You should be able to feel this problem. Back to the carb - yes, this can be heat induced. I'm assuming everything is in it's stock place (if so, there should be no modifications necessary - it should run as designed very well) so that should rule out any vaporlock problems. You have a list of things now that you can check. Replace the kit parts in the carb when you've gotten to the end of the list. Good luck.

Posted on Nov 30, 2009

1 Suggested Answer

6ya6ya
  • 2 Answers

SOURCE:

Hi there,
Save hours of searching online or wasting money on unnecessary repairs by talking to a 6YA Expert who can help you resolve this issue over the phone in a minute or two.

Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.

Here's a link to this great service

Good luck!

Posted on Jan 02, 2017

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

I have a cub cadet commercial 42 in cut 14.0 kawasaki FC420V it will start fine idles for 20 sec then dies


sounds fuel related Mike, it is starving for fuel check everything with the fuel system. maybe rebuild the carburetor. kits are cheap.

Oct 02, 2016 | Cub Cadet Garden

1 Answer

Carburater replacement


  • Why do you need a new one?
  • Details in the main link for cleaning and replacing.
  • Carburetor replacement parts for 2006 Kawasaki KFX50 ... www.2wheelpros.com/oem-parts/2006-kawasaki-kfx50-ksf50-a6f... Original 2006 Kawasaki KFX50 (KSF50-A6F) Parts. Search Carburetor parts using manufacturer microfiche assembly diagrams.
  • 2006 Kawasaki KFX50 KSF50A CARBURETOR Parts, 2006 Kawasaki ... www.bikebandit.com/oem-parts/2006-kawasaki-kfx50-ksf50a-carburetor/... 2006 Kawasaki KFX50 KSF50A CARBURETOR Parts at BikeBandit.com. The Web's most trusted source for 2006 Kawasaki KFX50 KSF50A CARBURETOR OEM Parts.
  • 2008 Kawasaki KFX50 (KSF50-B8F) - CARBURETOR ... - ... www.2wheelpros.com/oem-parts/2008-kawasaki-kfx50-ksf50-b8f... 2008 kawasaki kfx50 (ksf50-b8f) - carburetor ... 2008 ksf50b8f (932) schnee white; air cleaner; battery; belt converter; carburetor(b8f/b9f) chassis electrical equipment;
  • Kawasaki ATV Parts 2006 KSF50A6F KFX50 CARBURETOR Diagram www.partzilla.com > Kawasaki Parts > Kawasaki ATV Parts Search for Kawasaki ATV Parts 2006 ... Parts / Kawasaki ATV Parts / 2006 / KSF50A6F KFX50 Kawasaki ATV Parts 2006 KSF50A6F KFX50 CARBURETOR Diagram ...
  • 2008 Kawasaki KFX50 (KSF50B8F) Carburetor(B8F/B9F ... www.kawasakipartshouse.com/oemparts/a/kaw/500b50d3f8700223e47963d1/... Shop our large selection of 2008 Kawasaki KFX50 (KSF50B8F) Carburetor ... Kawasaki; ATV; 2008; ... or any Replacement Parts! Kawasaki Parts House is ...
  • Kawasaki KFX50 KFX 50 Carburetor Carb 15003-S004 Fuel Gas ... www.amazon.com > ... > Parts > Fuel System > Carburetors Kawasaki KFX50 KFX 50 Carburetor Carb 15003-S004 Fuel Gas 2003-2006 New OEM
  • Kawasaki ATV Mini KSF KXF 50 Carb Carburetor Used Parts ' ... www.ebay.com/sch/sis.html?_nkw=Kawasaki+ATV+Mini+KSF+KXF+50+Carb... Find best value and selection for your Kawasaki ATV Mini KSF KXF 50 Carb Carburetor ... Kit Carb Repair KFS 50 KFX ... 2006 Kawasaki KFX KSF 80 Carburetor ...
  • 2006 kawasaki carburetor ' eBay www.ebay.com > Search > 2006 kawasaki carburetor Refine your search for 2006 kawasaki carburetor. Refine. more Format ... Kawasaki KFX 400, 2003-2006, Carb / Carburetor Repair Kit - KFX400 ... $34.50. List price: ...

  • Go to Bing homepage

    Jul 09, 2016 | kawasaki 2006 KFX 50

    1 Answer

    My Kawasaki twin engine model FD 590 on my lawn tractor sputters, looses power and shuts down after about 15 min of running. Will star after it cool down. Cause please??


    Immediately check for spark after it dies. A failing ignition module will quit after it gets hot (about 10 minutes) then work again after it cools. Other causes could be a blocked tank vent; try to run till it starts to act up and loosen the fuel cap. See if it starts to run right again or if it does die it starts right back up. A sticking shut-off solenoid, sticking float needle or partially clogged fuel filter can also cause these symptoms. They let some fuel in but not enough and eventually the motor starves for fuel. then slowly the fuel fills back into the bowl and it will run again for awhile till it runs out of gas again.

    Sep 01, 2014 | Garden

    1 Answer

    Starts stalls


    contaminated or water in the fuel is most likely the culprit here.
    drain the tank and carb (small screw at bottom of carb float bowl)
    Add fresh fuel from a CLEAN fuel source. Best to completely drain your fuel can and fill it up with fresh fuel. That way if the fuel can is the culprit you eliminated doing this twice.
    What happened was fuel sits on top of water, this is why the bike would still idle. The idle circuit in the carb pulls fuel from a higher point than the main jet. This is also why when you hit the throttle it would just die, it was sucking most like something other than fuel.

    Apr 02, 2014 | kawasaki KX 450 F Motorcycles

    1 Answer

    2006 Kawasaki KDX 50 will not idle


    Hi, Anonymous and the usual suspects are:
    1. Fuel cap or fuel tank is not venting properly.
    2. Fuel filter clogged.
    3. Fuel line pinched or kinked.
    4. Vacuum line from the petcock to intake manifold cracked.
    5. Float needle and seat sticking.
    6. Float level too low.
    7. Carburetor bowl vent line clogged/blocked/pinched.
    8. Idle adjusting screw set too low.
    9. Air/fuel mixture screw set too lean.
    10. Idle port, transfer ports, slow air jet clogged.
    11. Slow fuel jet clogged.
    12. Faulty fuel pump.
    13. Faulty auto choke or wiring connection.
    For more information about your issue and valuable "Free" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
    http://www.kawasakimotorcycle.org/forum/mechanics-corner/124659-kdx50-starts-then-dies-wont-idle-long.html
    Dirtbike How To Ajust Your Idle Screw
    Kawasaki KFX50 Service Manual
    OEM Parts for Kawasaki
    Kawasaki KFX50 Owner Manual

    Btw, I’m available to help over the phone in case u need at https://www.6ya.com/expert/gregg_c0ec1df182c7330e


    Mar 01, 2014 | 2006 kawasaki KDX 50

    1 Answer

    I have a troy built riding mower it starts up fine , runs 10 or 15 minutes, then it starts spuppering and dies. then it acts like its flooded when you try tostart it again. then the other day while tr


    is it starving for gas the gas cap vent could be plugged keeping the fuel from flowing leave the cap loose and run it/are you loosing spark when this happens like the coil is going bad?

    May 08, 2012 | Garden

    1 Answer

    2007 Kawasaki EL 250 Eliminator quits running while riding


    Hi, Anonymous and the usual suspects are:
    1. Severely discharged or a damaged battery should have 12.5 volts or more and be able to pass a proper "LOAD" test if necessary, you may have a preliminary reading of 12.5 volts or more but little or zero amperage the battery is faulty and must be replaced, AGM batteries fail in this scenario more so than lead-acid batteries.
    2. Failed alternator/generator and or voltage regulator.
    3. Loose or corroded battery terminals and or cables especially the "NEGATIVE" cable, look for loose, corroded, or broken connectors inside the cable harness at "BOTH" ends.
    4. Failed main circuit breaker or ignition switch, check for loose connections and continuity.
    5. Failed system and or ignition relay, check for continuity.
    6. Failed ignition coil, stator, magneto, ignition/electronic module.
    7. Failed CKP, CPS, CMP, MAP, TPS, or BAS sensor, corroded, loose or broken wire connector pins/sockets.
    8. Throttle cables and or idle speed improperly adjusted hot idle speed should be 950 RPM to 1000 RPM.
    9. Faulty neutral, side stand or clutch lever safety switch.
    10. Faulty or corroded kill switch.
    11. Accelerator pump damaged or not working.
    12. Water or dirt in the fuel system, carburetor or filter.
    13. Restricted, blocked or kinked fuel line.
    14. Fuel tank empty.
    15. The gas cap is not venting properly or fuel tank venting system blocked, loosen gas cap and go for a test ride.
    16. A failed fuel pump, pressure regulator and or fuel injectors.
    17. Vacuum line from intake manifold to petcock broken, cracked, or not attached, carburetor vent line plugged.
    18. Needle and seat stuck closed in the float bowl.
    19. Petcock clogged or damaged.
    20. Lean angle switch is faulty or needs adjustment.
    21. Catastrophic engine failure, perform a compression test.
    For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
    MY BIKE JUST STOPPED RUNNING WHILE WAS RIDING
    Bike died while riding down highway
    Kawasaki EL 250 Eliminator Service manual Free Download Borrow and...
    OEM Parts for Kawasaki
    KAWASAKI EL250 Owner Manual

    Btw, I’m available to help over the phone in case u need at https://www.6ya.com/expert/gregg_c0ec1df182c7330e

    Feb 18, 2018 | 2007 kawasaki EL 250 Eliminator

    1 Answer

    Engine shuts off after about 10 minutes of use


    Try loosening the gasoline cap on the engine. My snowblower acted the same way until a mechanic told me it sounds like the engine is not getting enough air. Some gasoline cap vents go bad and starve the engine. If your engine continues to run you can buy a new gas cap.

    Mar 12, 2009 | Briggs & Stratton Garden

    Not finding what you are looking for?
    2003 kawasaki KLR 250 Logo

    2,597 people viewed this question

    Ask a Question

    Usually answered in minutes!

    Top kawasaki Experts

    Arnie Burke
    Arnie Burke

    Level 3 Expert

    5884 Answers

    Marvin
    Marvin

    Level 3 Expert

    85020 Answers

    richard libby

    Level 2 Expert

    208 Answers

    Are you a kawasaki Expert? Answer questions, earn points and help others

    Answer questions

    Manuals & User Guides

    Loading...