Question about Keeway Motorcycles
My Keeway 200cc superlight speedometer is showing red light beam this happened after I washed the motorcycle and also the brake light stopped working need help?@
Hi, Aaron moisture, condensation, rain, or bike washing can make the bike run sluggish, not able to rev, and misfire. Older bikes, engine configuration, and exposed electrical components are at the front of the line for acting up. During the diagnostic procedure spray Electrical Contact Cleaner on corroded wire connectors/pins/sockets etc. and apply a liberal amount of "DIELECTRIC" grease to the mating harness/wire connectors. WD40 works great for eliminating suspect areas in your quest to find the real offending gremlin.
For additional insurance you can spray a High Temp Clear Coat on the most vulnerable areas it will work like Scotch Guard does on fabric. Fabricate a rubber or plastic splash guard to deflect water coming off the front wheel getting to the front cylinder spark plugs. The design should be adequate for its purpose with the least amount of airflow restriction to cool the cylinders. The usual suspects are:
1. Air filter soaked with water.
2. Water in the fuel system gas tank and carburetors.
3. Wet ignition coil packs.
4. Spark plug boots wore out or loose allowing water to enter.
5. Spark plug cables old and cracked check for spark leakage in the dark.
6. Spark plug wells filled up and drain holes clogged.
7. Water in a wire harness that has exposed open ends and have a sharp bend or crimp allowing the liquid to form its own pool of potential threats to chaffed wiring.
8. Sensitive fuel tuners and downloaded ECM remaps may get confused with the abnormal cylinder temperature difference in a V-4 engine configuration.
If your bike will not run right or even start after going through the checklist, despair not, letting it sit for a couple of days in a warm environment is like an eviction notice for the Gremlins and then your bike will be back to its old self.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
Rear brake light not working fixed
Motorcycle Dash Warning Lights
Keeway superlight 125 service manual
Keeway Superlight 200 Parts Catalog pdf
Keeway RKV200 Electrical Diagram Eng pdf
Keeway Cruiser 250 Owners Manual Eng pdf
Btw, I’m available to help over the phone in case u need at https://www.6ya.com/expert/gregg_c0ec1df182c7330e
Posted on Nov 03, 2017
Hi, be carefull red lights are always a sighn of trouble !!!
in your case please check the wiring connection at the oil pressure gauge (usualy in the front of crankcase ) As for the tail bake light, also check wiring connections at the brake pedal switch and front brake switch ( under brake lever) Also check bulb. It will bea good idea to spresd som wd40 all over the electrical connections . Hope this helps
Posted on Nov 03, 2017
Save hours of searching online or wasting money on unnecessary repairs by talking to a 6YA Expert who can help you resolve this issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
Here's a link to this great service
Posted on Jan 02, 2017
You probably have the low side of your bulb blown check the bulb if that dont fix it ck your conector.if your dimmer switch was bad it wouldnt work on eather side. I will try to get you a diagram for the fuse box. PHIL.
Posted on Jan 06, 2009
SOURCE: keeway superlight 125 adjusments
Pull the slide out of the carb then move the clip on the jet needle down one or two notches. This will richen the low range fuel mix. You can also get a rear sprocket with about 4 more teeth. This will get you off the line and out of the corners faster BUT it will also lower your top speed.
Please rate this solution. Thanks supergunner!
Posted on Apr 17, 2009
SOURCE: were I can download keeway
this a the keeway website
although recently the manual wont open i think it may be under maintance/update. but it is always worth going back to the website now then just to check.
best of luck.
Posted on Sep 04, 2010
Tips for a great answer:
May 01, 2018 | 2007 Keeway Superlight 125
Feb 17, 2018 | 2009 Keeway Superlight 125
Aug 29, 2017 | Keeway Motorcycles
Apr 23, 2014 | 2007 Keeway Superlight 125
Oct 02, 2013 | 2007 Keeway Superlight 125
Mar 27, 2013 | 2008 Keeway Superlight 125 II
May 24, 2012 | 2008 Keeway Superlight 125 II
Dec 13, 2009 | Keeway Superlight 125 II Motorcycles
Nov 06, 2009 | 2008 Keeway Superlight 125 II
Mar 13, 2009 | 2008 Keeway Superlight 125 II
Jan 19, 2013 | 2009 Keeway Superlight 125
125 people viewed this question
Usually answered in minutes!