You state the cable is properly adjusted.
What about the clutch push rod adjustment, in the center of the pressure plate?
http://www.aim-tamachi.com/instructions/VP-IP-04-L.JPG
SOURCE: clutch snatching Madass 125cc
Could be burnt, or scorched clutch discs. DId you check the oil lately? I believe the Madasses have a wet clutch, right? Hope you didn't burn up the whole clutch basket. But you may have. Check the oil now!!!
SOURCE: clutch not engaging properly
The clutch is not dis-engaging properly. Cables can stretch a bit. There shou;ld be an adjuster either at the clutch handle or at the transmission. Just take most, not all, of the slack out of the cable.
You should be back to normal now.
Please rate this solution as "FixYa" or post a comment if the problem is still present. Thanks!
SOURCE: 1997 Honda Magna VF45c 750 clutch adjustment
Did you do an oil change recently? Sometimes a motor cycles clutch shares the oil with the engine and a different kind of oil then the bike requires will cause the clutch to slip. This happens alot especially if someone switches to some types of synthetic oil when the bike had regular oil before the oil change.
SOURCE: 2005 TTR 125 will not shift into first gear
This is one of those issues that is really tricky to diagnose over the net but would likely take a few minutes to diagnose in person.
When it does drop into gear, does it jump or stall? Will it idle in gear, stopped with the clutch pulled in?
My initial thought is that the clutch is not being fully released (the plates are still in firm contact with eachother).
More than likely, the resolution is a fairly simple adjustment.
Testimonial: " "
SOURCE: I put some new 10 40w oil in the case and took
Not being able to see the bike makes it hard to assess. Get your self a manual, if you haven't got one, go to http://www.carlsalter.com/motorcycle-manuals.asp , and download one. Once you have it apart you will be able to see the damage, and rectify it, and you may even work out what caused it. Sounds to me as if you blew a seal, whether from to much oil or not is very hard to say.
170 views
Usually answered in minutes!
×