Question about 2003 Yamaha YZ 125
I have a 2005 yz125 and the bike runs well in low to mid power but when I open the throttle there is no power. It feels like the gas cuts off and the bike **** down. What do I need to do to clean the carb? Do I just pull it off and spray carb cleaner? Do I need to double check anything else? Thanks in advance for the help...
ALWAYS have a fire extinguisher on hand when working on carburetors.
Remove the water trap bowl at the bottom of the petcock, (gas valve). Is there any water or trash in the bowl? Drain a cup of gas from the tank. Is there any water or trash in the cup? Dump it, clean it and re-mount it, ( not all bikes have a water trap bowl ).
Drain the carburetor. There should be a large plug on the bottom of the carb float bowl. Remove the plug then replace it after the fuel drains. Turn the gas back on and wait a minute for the carb to fill with gas. If the bike doesn't start and run properly then shut off the gas and remove the carburetor from the engine.
Remove the float bowl and clean the entire carb with a spray carb cleaner from the auto parts store. Wear protective goggles to avoid getting spray in your eyes. Spray into all the little airways and fittings in the carb. Remove the idle screw and the air screw on the outside throat of the carb and spray into the screw holes as well.
< < READ CLOSELY > >
Be sure to put these two screws back in the same hole they came out of. IMPORTANT > do not tighten these two adjusters down. Only screw these in until they LIGHTLY seat. Now turn each adjuster one and one half turns outward. Put the rest of the carb back together, clean the air filter and install the carb. Let the float bowl fill then start the engine. This process should get you back on the road. Post a comment to get back to me if it doesn't.
A “very helpful” rating for this answer? Thanks
Posted on Jun 16, 2009
Save hours of searching online or wasting money on unnecessary repairs by talking to a 6YA Expert who can help you resolve this issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
Here's a link to this great service
Posted on Jan 02, 2017
Tips for a great answer:
Oct 23, 2013 | 2004 Aprilia RS 125
Mar 17, 2017 | Motorcycles
Oct 21, 2010 | 2001 kawasaki ZX-6R Ninja
Oct 10, 2009 | 2003 kawasaki KX 250
Aug 18, 2009 | 2002 Honda CR 125 R
Aug 10, 2009 | 2008 Aprilia SX 125
Jun 28, 2009 | 1981 Suzuki GS 750 L
Jun 01, 2009 | 2004 Honda VTX 1300
May 14, 2009 | 2003 Yamaha YZ 250
4,262 people viewed this question
Usually answered in minutes!
Step 2: Please assign your manual to a product: