There is a better than not posibility that your carb is gummed up from sitting for a long period of time. The BEST way to overcome this problem is return to the dealer and ask them to clean and adjust your carb. You can do it ... if you have proper tool and cleaners. It will not hurt at all to have your 14 year old Kawasaki properly attended to as a new owner. After you get this this repaired, I recommend you use a guel conditioner which will lessen the occurrence of gum build up on your machine due to inactivity.
SOURCE: Vulcan 1500 classic starter
very simple to replace only 2 wires i believe they r just tight to get to and usually in a bad spot and just usually 2 or 3 bolts and it drops when u pull iy off look and see if the gears inside looksgood and not wore out
SOURCE: remove a gas tank
there are 2 bolts at the front of the seat, takeoff the seat, unsrew the bolts. that is the only thing holding it on. push the tank forward a bit, then lift up. there are breather tubes under the tank. be careful, they are difficult to get back on depending on the length. there are 2 bolts at the front of the seat, takeoff the seat, unsrew the bolts. that is the only thing holding it on. push the tank forward a bit, then lift up. there are breather tubes under the tank. be careful, they are difficult to get back on depending on the length.
SOURCE: 1992 kawasaki Vulcan 750 stops running
Sounds like what you realy need to do is remove the carb jets and give them a good clean , this if I am right is the twin V 8 valve engine with twin Klhein carbs , make sure also your air filter is not dirty and check tank fuel filter ,, other than that you may be intrested in the manuel obtainable from this site
http://www.haynes.com/products/sfID1/8/sfID2/9/sfID3/81/productID/399
hope this helps good luck .. and Live long and prosper lol .. Regards Vortash
SOURCE: 1992 kawasaki Vulcan 750 stops running
Check the intake manifold/s, even a small leak will make it run poor. Being stored for five years then putting it into use, you may have a blocked main jet. Sea-foam is a great product and I would have used that product to store the bike but not to get it running. It is slow acting so it doesnt work like carb cleaner.
SOURCE: 99 kawasaki vulcan 1500 classic will not idle
if u can tuen the throttle and it still run ..its ur idle,u need to adjust ur idle adjustment screw ur manual can help u find this
309 views
Usually answered in minutes!
×