2004 Suzuki VL 800 Volusia Logo
Posted on Jan 20, 2009
Answered by a Fixya Expert

Trustworthy Expert Solutions

At Fixya.com, our trusted experts are meticulously vetted and possess extensive experience in their respective fields. Backed by a community of knowledgeable professionals, our platform ensures that the solutions provided are thoroughly researched and validated.

View Our Top Experts

Engine skips, won't go over 55 mph. Works fine below that.

My 2004 Suzuki VL-800 cuts out when attempting to go over 55 mph (Works fine below that.). Has worked fine for the 6 mo. I've owned it. 44,000 miles and may have Never had new spark plugs. Yesterday, I gunned it while traveling up a mile-long bridge span (40 to 75 mph in a short time). 1 hour later, problem started. Shifting down to 4th gear, the bike still won't go over 55 mph. Also, just fill the tank with regular gas (always have used regular gas, but never pushed performance like yeaterday) Could it be spark plugs, fuel pump, ignition. Tested without air cleaner -- no help.

  • 2 more comments 
  • Anonymous Feb 22, 2009

    i have a similar prob. after i wash my bike or its been raining hard, it would't go over 50/60. turned out it was firing on one cylinder (the back only) coz the drain hole was blocked in the casing keeping the plug surrounded in water. if this what is happening to you, dont go too far or (like mine) your bottom muffler will go blue. hmph....... JV

  • heater33 May 15, 2009

    My motorcycle starts cutting out when I hit 55 mph. Not real bad, but noticeable. I can get up to 70, but it seams like it struggles to get there

  • Anonymous May 11, 2010

    check eletrical system

    check spark plug gaps

    check coil

    check if brakes binding

    check transmission fluid level (if wet)

    check clutch adjustment

    check fuel filter

    check fuel

    check compression

    check fuel lines

    check for obstruction in exhaust

    any emissions stuff - if so, check

  • Anonymous Mar 23, 2014

    seems to be common with the 1250 bandit, the fuel pump seems faulty ordered a new one and within an hr same problem, bike will barely reach 80 mph and can only give it 1/4 throttle before it cuts out. it is fuel injected and has an inner tank fuel pump.

×

1 Answer

Anonymous

Level 2:

An expert who has achieved level 2 by getting 100 points

MVP:

An expert that gotĀ 5 achievements.

Governor:

An expert whose answer gotĀ voted for 20 times.

Scholar:

An expert who has written 20 answers of more than 400 characters.

  • Expert 101 Answers
  • Posted on Jan 20, 2009
Anonymous
Expert
Level 2:

An expert who has achieved level 2 by getting 100 points

MVP:

An expert that gotĀ 5 achievements.

Governor:

An expert whose answer gotĀ voted for 20 times.

Scholar:

An expert who has written 20 answers of more than 400 characters.

Joined: Dec 18, 2008
Answers
101
Questions
0
Helped
53964
Points
224

Hi ..... Go through the above list, pay particular attention to fuel delivery ie blocked breather in tank, any filter fitted to tap or change in line filter if fitted. Easy to check, take off fuel delivery to carb (place container to catch fuel), start bike and fuel should come out a strong contant flow.
Let us know how you get on.

Add Your Answer

×

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

0helpful
2answers

2003 Suzuki VL 800 Volusia how to check the coolant level

You have to remove the cover on the lower left side of the motorcycle, then you can observe the coolant level indicator. See the link below.

Cooling System - Suzuki VL800 Service Manual [Page 29] ' ManualsLib
0helpful
1answer

What is the max rpm to run a vl 800 at

Found this in the Suzuki VZ800K5 Manual.\:

Chapter 9-20
"The fuel cut-off circuit is incorporated in this ECM in order to prevent over-running of engine. When engine
speed reaches 8000 r/min during running, this circuit cuts off fuel at the fuel injector."

Found this in the Suzuki VZ800K4 Manual ... The 04 does NOT have FI but this performs as I said above..

Chapter 8-16
"The fuel cut-off circuit is incorporated in this ignitor in order to prevent over-running of engine. When engine
speed reaches 8000 r/min during running, this circuit cuts off primary circuit for all spark plugs."
3helpful
1answer

What is the engine oil capacity and type of oil for a 2003 suzuki volusia vl800?

Hi, the oil for a vl 800 intruder 2001-2004 is
10w40 SG, it holds 3.4 litres, buy 4 litres and recheck level after initial starting,
Regards Paul
0helpful
1answer

The bike starts and runs fine however it has now started cutting out, when I slow right the engin cuts out and the oil light come on. all the eletrics are on but when i try to restart the bike its...

Mine has the same fault. The ignition sensor leaks to earth when it is hot so engine cuts out. I've had two sensors fitted. But They still leak to earth. Trying to get Suzuki to sort, permanently.
0helpful
2answers

Change coolant suzuki vl 800 motorcycle 04

my 2001 vl 800 speedometer will not work along with odemeter everthing else works but that<!-- from fixya rte -->
3helpful
1answer

2004 VL 800 Volusia: How do i refill the coolant on my 2005 suzuki vl80...

the coolant resivoir bottle is located behind the rear engine cover on the kick stand side
0helpful
1answer

Miles per gallon

I just purchased a 1995 VS 800 w/18,000 miles and it gets 50-60 mpg at 60 mph.
Not finding what you are looking for?

1,148 views

Ask a Question

Usually answered in minutes!

Top Suzuki Experts

Arnie Burke
Arnie Burke

Level 3 Expert

7339 Answers

Sean Wright
Sean Wright

Level 3 Expert

2045 Answers

Bob G

Level 2 Expert

104 Answers

Are you a Suzuki Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...