Question about 1994 Suzuki DR 350 S
My 97 Suzuki dr350 backfires and sounds like a miss fire @
Posted by Anonymous on
Hi, Anonymous and the usual suspects are:
1. Severely discharged or a damaged battery should have 12.5 volts or more and be able to pass a proper "LOAD" test if necessary, you may have a preliminary reading of 12.5 volts or more but little or zero amperage the battery is faulty and must be replaced, AGM batteries fail in this scenario more so than lead-acid batteries.
2. Check battery terminals for damage or corrosion, check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter if necessary.
3. Faulty main circuit breaker and or connections.
4. Faulty ignition coil and or connections.
5. Faulty spark plug, oil or gas fouled, wrong heat range or service type, wrong gap, loose in the cylinder head, broken electrode or insulator.
6. Faulty spark plug cables, leaking or broken, internal damage check for spark leakage in the dark.
7. Faulty ignition module, switch, CKP, MAP, CMP, sensor and or any connector in the ignition circuit could have corroded, loose, or broken pins/sockets
8. Burnt exhaust valve or air leak in the exhaust system.
9. Improper valve clearance (too tight).
10. Check for generated diagnostic codes.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
Dirt bike won idle and backfires FIX
Posted on Feb 21, 2019
Save hours of searching online or wasting money on unnecessary repairs by talking to a 6YA Expert who can help you resolve this issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
Here's a link to this great service
Posted on Jan 02, 2017
Did you sync the two carbs? If not the rear may be getting all the gas from the rear carb and none to the front. Twist throttle engine off and see if front carb cable is pulling the carb open.
Also unscrew the spark plug boot from the front spark plug wire and trim 1/8th inch off the wire and screw the boot back in. The plug wire end may be corroded on that wire.
Posted on Feb 08, 2010
Tips for a great answer:
May 19, 2017 | 1991 Suzuki DR 350 S
May 01, 2017 | 1992 Suzuki DR 350 S
Mar 13, 2017 | 1991 Suzuki DR 350 S
Dec 07, 2015 | Suzuki DR 350 S Motorcycles
Apr 01, 2014 | 1997 Suzuki VS 800 Intruder
Nov 06, 2017 | 1991 Suzuki DR 350 S
Aug 05, 2010 | 1994 Suzuki DR 350 S
May 19, 2010 | 1991 Suzuki DR 350 S
Jul 15, 2009 | 1994 Suzuki DR 350 S
132 people viewed this question
Usually answered in minutes!
Step 2: Please assign your manual to a product: