Problem with 800cc suzuki intruder 2002 2002 suzuki intruder 800cc amonth ago i changed all fuilds and brakes also plugs and filter brike ran really good yesterday a couple buddies wanted to go riding we went 300 mile stop got some thing to eat 20 mins or so started riding agone about 10 miles down about 65 mph bike was losing power come and go so pulled overtalked bike ran ok at 50 mph so we went on then bike started back firing about 2miles after that it died pulled over let it cool tried to start sound like no firier just spinnig so so checked each plug spark inboth checked fuel there is fuel put bike in first gear put a tow rope on it it pulled wheel spinning so not locked up all it does wen tring to start up is spin no firier
SOURCE: Engine skips, won't go over 55 mph. Works fine below that.
Hi ..... Go through the above list, pay particular attention to fuel delivery ie blocked breather in tank, any filter fitted to tap or change in line filter if fitted. Easy to check, take off fuel delivery to carb (place container to catch fuel), start bike and fuel should come out a strong contant flow.
Let us know how you get on.
SOURCE: 1989 tw200 yamaha won't start
G'day egdbcs . Ok.now lets see.You say good spark,so i'm presuming you are doing the old sight test.Try bending the arm on a know good sparkplug about 5-6mm,earth the plug and kick'er in the guts(crank it over)Be very carefull , high voltage danger.If there's still a good spark it's safe to say that there will also be a good spark under pressure in the combustion chamber,speaking of which you should also do a compression test,anything over 100psi should be ok. as i'm not to sure of the extent of the re-build,hopefully the valves were lapped and checked for straight and true and valve seals replaced,if you notice oil on the tip of the spark plug you could have a leaking valve seal or oil seal .Try putting a small amount of fuel directly into the combustion chamber ,tighten up the spark plug ,install the plug cap and.......Yeah ..You guessed it ..."kicker in the guts".If all the abouve are correct and true it should fire up.If it runs for 5-10 seconds then stops you've got some sort of fuel starvation problem , could be dirt in the carb,blocked idle jet ,or air passage or even the needle could have come off it's clip,believe me with an old bike like yours anything could be worn and loose inside that carby.The only other thing to consider is the timing.There may be a good spark but is it happening at the right time inside the engine???. I'll leave it all in your capable hands EGDBCS.Hope this helps to solving your worries. Chow for now......Tilleydog..
SOURCE: 94 GSXR 750 DIED WHILE RIDING AND WILL CRANK BUT NOT START
There may not be an in-line fuel filter on the bike. Most bikes don't come with them. Yes, the fuel petcock has two screen filters on one pipe and they can get clogged up. Remove the tank then remove the petcock and clean it. The gas in the tank should be dumped into a clear plastic storage bin so that you can see if there is any water in the gas as well as rust and trash. Your bike is 15 years old and the inside of the tank may be rusty. If so, Google “ kreem fuel tank liner “ or go to
www.http://www.4secondsflat.com/Fuel_Tank_Sealer.html
This will end the rust problem. Go ahead an install an in-line fuel filter. There is a drain plug on the lower left side of each carb. Drain each carb into a clear container and look for water and trash. You may need to clean the carbs but hold off to see if the other stuff fixes the problem.
Go to the site below where you can see a parts diagram for your specific bike. You will select the actual brand, year, model, etc., once you go to the site. Part numbers and prices are also shown. You can order parts from this site. In the event no price is shown on a particular part, the part is not in stock.
www.babbittsonline.com/pages/parts/viewbybrandand/parts.aspx
Please top rate this answer. Thanks!
SOURCE: Bogs down at 50 mph or over
this is an air intake problem check the air filter is clean also check air filter is the same model as original as some air filters require a carb retune to function properly
hope this helps
SOURCE: Yamaha TW 200 starts but won't run.
If the bike has sat for a long period of time without being run - the gas that is sitting in the carb(s) will shellac.. Then the carb(s) would need to be cleaned and "rebuilt"..
685 views
Usually answered in minutes!
×