Top 20
2001 Suzuki GSX-R 600 Questions & Answers
2001 Suzuki GSXR 600 starting trouble.
The stator is probably it..I had the same problem...After you change it the bike will run so much better. That's why it ran good with the new battery...Then it started draining it..It takes a special tool to get it out..
Gsxr 600 battery
I feel I need to get this message across to all bikers. YOU MUST NOT JUMP START YOUR BIKE IF YOU CONNECT IT TO A CAR,VAN OR TRUCK BATTERY YOU WILL KILL THE BATTERY. A motorcycle battery is far lower in power rate than the average small car.
Remove the old battery from the bike by disconnecting the negative lead first then the positive.
Get yourself a new battery fill with the acid supplied then charge it, DO NOT USE A CAR CHARGER IT WILL FRY THE BATTERY. USE A DEDICATED MOTORCYCLE BATTERY CHARGER WITH AN OUTPUT RATE OF 1 AMP MAX. A smart charger is the best bet or an Optimiser that you can connect to the bike battery and connect it to the the bike when not in use. This will maintain the battery power and voltage levels.
After charging refit the battery by connecting the positive lead first then the negative. Before trying to start the bike check the new battery voltage it should be between 12.5 volts and 13.2 approx. If the bike starts OK check the charge rate from the alternator connect a volt meter across the battery you should see an increase in volts up to approx 14.4 at 5,000 rpm. If so your alternator and rectifier/regulator are working. Hope this helps.
Fuel pump stays on and floods motor
Not too sure about this but there are a couple of things to try. Fairly sure the fuel pump runs from a relay somewhere in the tangled mass we call a wiring harness. You will also have a dedicated fuse for the pump, the fuse is obviously OK. I would look for the relay and or check the ECU. Do the plugs spark? Sorry can't be more helpful.
Battery keep going dead
If the battery is dead after starting then you have a short in the starting system. If it only starts when you jump it, and I'm assuming your using a car to do this, then it sounds like the starter is using an unusual amount of current to start and is defective. A shorted starter will drain a battery instantly, but make sure the positive cable is not shorted to the frame anywhere first.
GSXR 600 K1 Won't start tries to fire up and the exhaust pops but that's all
Based off of the limited information, the solutions are going to be generalized.Visually check your battery for any acid build up. If you spot any, obviously some acid remove would be called for. Acid can sap a battery's output to a starter.Visually inspect fuel components. Fuel injectors on bikes tend to get clogged when they sit for a while. Especially on older models. Refer to a repair guide for your specific model for guidance on the procedure to inspect fuel injectors.Those two common starting problems for bikes. Without more information it is hard to offer a specific solution.
I have a 2001 Suzuki GSXR 600. It suddenly lost
Bikes don't actually have alternators. The charging system on a bike has a generator and a regulator/rectifier. The generator might cost you a little bit but the regulator/rectifier won't cost a lot. Chances are one of those went bad which creates a large power draw and doesn't allow your battery to charge. Seems like it's a regular occurance with the K1's. I would suggest getting a repair manual and fixing it yourself. Might take you a day or two but it'll save you a lot in labor.
2001 suzuki gsxr 600 ignition problems
Sounds like you have a short in the electrical system possibly around your fuze box. Best thing to do is to just pull off all your plastics and trace the electrical system, looking for exposed wires or damaged wires.
Popping noise coming from front
hi it sounds like your front sproket is really worn and hooked when you turn the chain its not releasing the links smoothly ,replace it with a new one and check the condition of your chain it may be worth replacing a complete chain and sproket set as running a bike with a worn front sproket could lead to a back wheel locking up at speed if the chain jams
Replacing the stater,do i have to torque the
Do not torque your starter with a torque ratchet,You will break bolts,,,,It requires inch lbs.,,,not foot lbs,,,use a good ratchet and tighten the bolts.
Got 2001 gsxr 600! bike starts in (N) but stalls
Check you side stand safety switch . Suzuki uses a system that kills the motor if you put it in gear with the side stand down or put the side stand down while it is in gear and it is running.
Not finding what you are looking for?