20 Most Recent 2011 Bajaj Pulsar 180 Questions & Answers


Hi Johnny_mahmo and the usual suspects are:
1. Faulty wire connector corroded, broken, or loose pins/sockets.
2. Poor fuel mileage.
3. A slight change in exhaust sound and heavy fuel smell.
4. Spark plug electrodes black or sooty.
5. Loose or missing sensor o-ring
6. Check engine light comes on or flashes.
7. Overall poor engine performance; rough idling, stalling, surging, hesitation on acceleration, etc.
There is no video for testing a Harley Davidson Map Sensor, but there is one for a car. All map sensors work the same way no matter what type of vehicle the sensor is located. They all have three wires, on a Harley red is power, black is ground and violet with a white stripe is the signal/data wire. For more information about your issue, please visit the websites below. Good luck and have a nice day.
MAP Sensor Diagnosis and Understanding Function Pt1 Service Manual Bajaj Pulsar 220

Btw, I’m available to help over the phone in case u need at https://www.6ya.com/expert/gregg_c0ec1df182c7330e


2011 Bajaj... | Answered on Oct 09, 2019


Hi, Sreenath external oil deposits fall into 3 categories:
1. WEEPAGE is the oil that is sweated pass gaskets, seals, o-rings, and crankcase seams, it's covered by dry dust and is normal for older engines with lots of miles, no repair is necessary.
2. SEEPAGE is the same as weepage except the deposit is wet and confines itself to a specific area, the repair is optional depending on the owner's cleanliness criteria, the deposit location and the weight of his bag of "DRACHMA"
3. LEAKAGE is the same as seepage except it is enough to drop to the ground leaving a spot. Repair as necessary.
To find the source of your oil leak, start at the point where you see oil and trace its path going up and forward, blowing baby powder from the palm of your hand will help in those difficult to see areas if there is too much oil present then buy a spray can of engine degreaser apply it to the affected area then rinse off with a pressure wand or garden hose, use compressed air to blow off excess water or just let it drip dry, take your bike for a 15 minute ride and check for the leak.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
https://www.xbhp.com/talkies/help-me/16201-engineoil-leaking-problem-pulsar-180ug4.html
https://www.youtube.com/watch?v=v625arASyVw
Bajaj Pulsar 180 DTSi Workshop Manual
https://www.scribd.com/doc/69444853/Bajaj-180-Pulsar-UG4-Spares-List
Owner Manual Bajaj Auto

2011 Bajaj... | Answered on May 12, 2019


Hi, Binu and the usual suspects are:
1. Wheels and or tires are worn or damaged.
2. Engine/transmission/vehicle not aligned properly.
3. Primary chain is badly worn or links too tight as a result of insufficient lubrication or misalignment.
4. Engine to transmission mounting bolts loose.
5. Upper engine mounting bracket loose.
6. Ignition timing incorrect due to a poorly tuned engine.
7. Internal engine problem flywheels have shifted.
8. Broken frame.
9. Stabilizer links are worn or loose.
10. Rubber mounts loose or worn.
11. Rear fork pivot shaft nuts loose.
12. Front engine mounting bolts loose.
13. Worn out or broken universal joint on shaft drive models.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
https://www.xbhp.com/talkies/help-me/17151-pulsar-180-dtsi-problem.html
https://www.youtube.com/watch?v=D__0mlDLR1k
Bajaj Pulsar 180 DTSi Workshop Manual
https://www.99rpm.com/bajaj/parts.html
https://www.bajajauto.com/pdf/PULSAR_150_180.pdf

2011 Bajaj... | Answered on May 06, 2019


Hi, Anonymous I just loaned my brand new pair of listening ears to your local dealers chief technician so he could take your bike for a test ride and give you his professional opinion and estimate about your noise and repair cost. For more information about your issue, please visit the websites below. Good luck and have nice a day.
DOWNLOAD Bajaj Pulsar 180

Btw, I’m available to help over the phone in case u need at https://www.6ya.com/expert/gregg_c0ec1df182c7330e

2011 Bajaj... | Answered on Feb 08, 2019


Hi, Johnny for more information about your question and valuable "FREE" downloads that you will need please visit the websites below. Good luck and have a nice day.
Horrible noise overheating and loss of power
Seeking help with motorcycle rattle noise
engine rattle Honda Motorcycles FireBlades org
http://www.bcmtouring.com/imp/Pulsar_DTSi_Workshop_Manual.pd

Btw, I’m available to help over the phone in case u need at https://www.6ya.com/expert/gregg_c0ec1df182c7330e


2011 Bajaj... | Answered on Mar 09, 2016


Hi Awayonyi, you may have a bad main shaft seal and I am sorry you can't find the first and best tool you ever bought for your Bajaj but despair not for a mere $10 you can download another one. For more information about your issue, please visit the websites below. Good luck and have a nice day. DOWNLOAD Bajaj Pulsar 180

Btw, I’m available to help over the phone in case u need at https://www.6ya.com/expert/gregg_c0ec1df182c7330e

2011 Bajaj... | Answered on Nov 17, 2015


Hi Anonymous, I am sorry you can't find the first and best tool you ever bought for your Bajaj but despair not for a mere $10 you can download another one. For more information about your issue, please visit the websites below. Good luck and have a nice day.
How to adjust the jets on motorcycle carburetors
How to diagnose carburetor vacuum leaks on your motorcycle Two Stroke Scooter ATV Carburetor Settings And Adjustments 1of4 Basics...
Service Manual Bajaj Pulsar 220

Btw, I’m available to help over the phone in case u need at https://www.6ya.com/expert/gregg_c0ec1df182c7330e




2011 Bajaj... | Answered on Nov 17, 2015


Hi Preetam, I am sorry you can't find the first and best tool you ever bought for your Bajaj but despair not for a mere $10 you can download another one. For more information about your issue, please visit the websites below. Good luck and have a nice day.
https://www.quora.com/How-can-I-increase-the-mileage-of-my-pulsar-220f
How to get better best mileage R15 Pulsar 220 200 180 FZ16 FZ Fazer ZMR...
https://answers.yahoo.com/question/index?qid=20120116200014AAzJI1S
my new pulsar 220f speedlines claim 133kmph giving mileage of 48 3 in...
Service Manual Bajaj Pulsar 220

Btw, I’m available to help over the phone in case u need at https://www.6ya.com/expert/gregg_c0ec1df182c7330e


2011 Bajaj... | Answered on Nov 17, 2015


Hi, Sanan002000 and the usual suspects are:
1. Throttle cables misaligned or misrouted.
2. Damaged or restricted fuel tank venting system.
3. Inlet system air leak.
4. Vacuum piston malfunction.
5. Accelerator pump leaking or no output.
6. Plugged bowl vent.
7. Fuel level in bowl too low.
8. Restricted fuel supply passages.
9. Plugged jets or passages.
10. Worn or damaged needle or needle jet.
12. The enricher valve not seated or leaking.
For more information about your issue please visit the websites below. Good luck and have a nice day.
Service Manual Bajaj Pulsar 220

Btw, I’m available to help over the phone in case u need at https://www.6ya.com/expert/gregg_c0ec1df182c7330e

2011 Bajaj... | Answered on Nov 17, 2015


Hi, Funky_chauha the following applies to carbureted also fuel injected models and the usual suspects are:
1. Severely discharged or a damaged battery, 9 volts or lower.
2. Faulty alternator/generator and or voltage regulator.
3. Check battery terminals for damage or corrosion, check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter if necessary.
4. Faulty main circuit breaker or ignition switch, check for loose connections and continuity.
5. Faulty system and or ignition relay, check for continuity.
6. Faulty ignition coil, ignition/electronic module.
7. Faulty CKP, CPS, CMP, MAP, TPS, O2, or BAS sensor, corroded, loose or broken wire connector pins/sockets.
8. Water or dirt in the fuel system, carburetor or filter.
9. . Restricted, blocked or kinked fuel line.
10. Fuel tank empty.
11. The gas cap is not venting properly or fuel tank venting system blocked.
12. A faulty Fuel Pump, pressure regulator and or fuel injectors.
13. Vacuum line from intake manifold to petcock broken, cracked, or not attached, carburetor vent line plugged.
14. Needle and seat stuck closed in the float bowl.
For more information about your issue, please visit the websites below. Good luck and have nice a day.
DOWNLOAD Bajaj Pulsar 180

Btw, I’m available to help over the phone in case u need at https://www.6ya.com/expert/gregg_c0ec1df182c7330e

2011 Bajaj... | Answered on Nov 17, 2015


Hi Abhi8055 and the usual suspects are:
1. Insufficient oil supply, or oil not circulating.
2. Insufficient air passing over the engine.
3. Heavy carbon deposits.
4. Ignition timing retarded due to faulty MAP, CKP, O2, and/or CMP sensors.
5. Leaking intake or exhaust valve.
For more information about your issue, please visit the websites below. Good luck and have a nice day.
Service Manual Bajaj Pulsar 220

Btw, I’m available to help over the phone in case u need at https://www.6ya.com/expert/gregg_c0ec1df182c7330e

2011 Bajaj... | Answered on Nov 17, 2015


Hi Kartik_nraja, you may want to get a second opinion and I am sorry you can't find the first and best tool you ever bought for your Bajaj but despair not for a mere $10 you can download another one. For more information about your issue, please visit the websites below. Good luck and have a nice day.
DOWNLOAD Bajaj Pulsar 180

Btw, I’m available to help over the phone in case u need at https://www.6ya.com/expert/gregg_c0ec1df182c7330e

2011 Bajaj... | Answered on Nov 17, 2015


Hi Malik_jaat20, for more information about your question please visit the website below. Good luck and have a nice day.
http://www.bikebandit.com Service Manual Bajaj Pulsar 220

Btw, I’m available to help over the phone in case u need at https://www.6ya.com/expert/gregg_c0ec1df182c7330e

2011 Bajaj... | Answered on Nov 17, 2015


Hi, Joecords_12 and the usual suspects are:
1. Spark plugs in bad condition or have an improper gap or are partially fouled.
2. Spark plug cables in bad condition.
3. Battery nearly discharged, should have 12.5 volts.
4. Discharged battery, check battery terminals for damage or corrosion, check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter if necessary.
5. Throttle controls not adjusted correctly.
6. Water or dirt in the fuel system.
7. Water or dirt in the carburetor.*
8. Intake air leak.
9. Fuel tank vent hose and vapor valve plugged, or fuel line closed off, restricting fuel flow.*
10. Enricher valve inoperative.*
11. Engine lubricant to heavy (winter operation).
12. Ignition is not functioning properly (possible sensor failure).
13. Faulty ignition coil.
14. Valves sticking.
* Carbureted models.
For more information about your issue, please visit the websites below. Good luck and have a nice day.
Service Manual Bajaj Pulsar 220

Btw, I’m available to help over the phone in case u need at https://www.6ya.com/expert/gregg_c0ec1df182c7330e

2011 Bajaj... | Answered on Nov 17, 2015


Hi, Sid1995 for this situation I would call my local dealer or reputable shop's service/parts department and inquire about any possible quick fix or parts inquiry. If necessary transport your vehicle to the dealer or shop and have a professional technician take it for a test drive, if it is in running condition, and give you a written estimate of repairs and answer any specific questions you may have about your issue. For more information about your issue please visit the website below. Good luck and have a nice day.
http://www.bikebandit.com/
Service Manual Bajaj Pulsar 220

Btw, I’m available to help over the phone in case u need at https://www.6ya.com/expert/gregg_c0ec1df182c7330e

2011 Bajaj... | Answered on Nov 17, 2015


Hi Anonymous, for more information about your question please visit the website below. Good luck and have a nice day. How much is BAJAJ 150cc in Kenya Prices Of India

Btw, I’m available to help over the phone in case u need at https://www.6ya.com/expert/gregg_c0ec1df182c7330e

2011 Bajaj... | Answered on Nov 17, 2015


Hi, Abhishek for this situation I would call my local dealer or reputable shop's service/parts department and inquire about any possible quick fix or parts inquiry. If necessary transport your vehicle to the dealer or shop and have a professional technician take it for a test drive, if it is in running condition, and give you a written estimate of repairs and answer any specific questions you may have about your issue. For more information about your issue please visit the website below. Good luck and have a nice day.
Service Manual Bajaj Pulsar 220

Btw, I’m available to help over the phone in case u need at https://www.6ya.com/expert/gregg_c0ec1df182c7330e

2011 Bajaj... | Answered on Nov 17, 2015


Hi Vinayak, I am sorry you can't find the first and best tool you ever bought for your Bajaj but despair not for a mere $10 you can download another one. For more information about your issue, please visit the websites below. Good luck and have a nice day.
Service Manual Bajaj Pulsar 220

Btw, I’m available to help over the phone in case u need at https://www.6ya.com/expert/gregg_c0ec1df182c7330e

2011 Bajaj... | Answered on Nov 17, 2015


Hi, Anonymous for this situation I would call my local dealer or reputable shop's service/parts department and inquire about any possible quick fix or parts inquiry. If necessary transport your vehicle to the dealer or shop and have a professional technician take it for a test drive, if it is in running condition, and give you a written estimate of repairs and answer any specific questions you may have about your issue. For more information about your issue please visit the website below. Good luck and have a nice day.
DOWNLOAD Bajaj Pulsar 180

Btw, I’m available to help over the phone in case u need at https://www.6ya.com/expert/gregg_c0ec1df182c7330e

2011 Bajaj... | Answered on Nov 17, 2015

Not finding what you are looking for?
2011 Bajaj Pulsar 180 Logo

93 questions posted

Ask a Question

Usually answered in minutes!

Popular Products

Top Bajaj Experts

richard libby

Level 2 Expert

209 Answers

Arnie Burke
Arnie Burke

Level 3 Expert

5954 Answers

Marvin
Marvin

Level 3 Expert

85206 Answers

Are you a Bajaj Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

View Most Popular

Pulsar 180 Bajaj

  • Pulsar 180 Bajaj

Most Popular Question

condisan bike

  • Motorcycles
Loading...