Jawa 640 Tramp - Popular Questions, Answers, Tips & Manuals

The 640 ***** is gone, but here's the dealer for Jawa in Australia.

Matt Jones Motorcycles PTY ltd.
MJM Speedway Spares
700 Bulmans Road
Melton, Victoria 3337
Australia

Tel.: ++61 397 460 134
Fax: ++61 397 460 561

23 hp (17.2 kw) @ 5250 rpm

ProClean is good stuff but not worth the money. The only reason I had it was because I won a create of it at our clubs Supercross race it's too expensive in my opinion. I buy 40 litre containers of stuff called TFR which stands for Traffic Film Remover, it basically is a detergent like ProClean, Simple Green and all the others, only it costs a fraction of the price and isn't deluted. This means you can delute it to your own strength for different causes. You can see it removing dirt as you watch, like someone said above. You can not use it pure on the bike however, it will make alloy parts go dull - as my buddy found out lol. ,,,

You may want to try a 'color match ' polish.Try your local Detail Shop to get the best suggestion as to what they use.

Drain it and put in fresh check for motorhead kracks white means water in engine.,,

17 liters (4.5 gallons)

More information would help - why do you need to replace the stator plate? What's the trouble? Why can't the existing stuff be repaired or components replaced. There have been several versions of the Babetta, the first moped to use a contactless transistorised ignition, unfortunately obtaining spares, if they are available might mean buying from Germany, Czechoslovakia or Latvia. An alternative could mean fitting a one piece ignition module from a lawn mower, chainsaw or strimmer...

Try Carl Salter website & scroll down to Jawa section, might be something suitable. http://www.carlsalter.com/classic-bike-service-manuals.asp

If the clutch is engaging but the motor is dying its probably a dirty carb jet, float or fuel starvation.

saya pengen mebukan blokir dari temana saya gimana cara bukanya

Remove the carb, then the float bowl at the bottom of the carb then clean the carb with spray carb cleaner. Spray into each and every drill hole and jet you can find. Use goggles so you don't accidently get cleaner in your eyes. Please, rate my answer, thanks. Reset the air and throttle screws, one and one half turns outward from a lightly seated position. Please, rate my answer. Thanks.

Here is the 2004 Jawa 650 Classic CDI Diagram from the Manual:
http://www.4shared.com/document/cDeNQa2c/2004_Jawa_650_Classic_CDI.html

Here is the 2006 Jawa 650 Classic CDI Diagram:
I’m happy to help further over the phone at https://www.6ya.com/expert/jeremy_69f3cc28d95bf514

Maybe this guy can help.
http://www.100megsfree3.com/ahrmanw/bpp.htm

Hope it is usefull.

call customer care and say that you need the puk code.dont type puk wrongily 10 times,it can permanently block your sim card.

I assume this posting was a test. I answer it simply to remove material that does not apply to the category....

its under your seat next to the batary.Its a blinker relay with 2 wires going to it

I assume this posting was a test. I answer it simply to remove material that does not apply to the category..

Check out abebooks.com

This link should help you find what you need. i hope this helps please rate this an thank you http://www.cybermotorcycle.com/components/books_manuals.htm

search archway mc salvage in st louis may be able to salvage piston-try getting a mc rebuild manual