Audi gearbox romovel and refit

It is inside the transmission.

I’m happy to help further over the phone at https://www.6ya.com/expert/anthony_dda4e0152e94f3c0

Hi Craig,
I'd suggest that the oil seal which seals between the torque converter neck and the gear box casing is damaged and will need replacing. The job seems simple but in fact can result in breaking the gearbox oil pump, when the torque converter is refitted to the gear box. the neck has to align with the gears inside the gear box and the oil pump, if the torque converter is not fitted correctly the damage I've mentioned will take place when refitting box.
If you would like to proceed let me know.
Regards Johngee10

The switch for reversing light is placed on the right side of the gearbox for Audi 1.9 TDI 2003 model 6 speed.
Switch: M14 x 1,5 & Part number: 01E941521A.
See picture below:


Please do rate my response. Thanks!

On 2003 Audi A4 1.9 TDI the "SERVICE" message can be reseted only using: VAS, VAG-COM, Bosch KTS, Texa, ... diagnostic scantool. Not possible without this equipment connected to the data link connector (DLC) of the car !

For Audi A4 model 2003 1.9 TDI 131 HP the board computer message ,,Service in 2400 km 29 tagen" means: Service due in 2400 km, or in 29 days - which one: 2400 km or 29 days will be first covered. It's very simple!

This makes switching sensor stuck to the subject when the reverse ligts is ON/OFF is on the side of the gearbox
Very easy to replaced

Hi,

Just checking.... it is a manual gearbox?

You may need a special tool for the drain plug and a 17mm allen key for the filler (some use the special drain tool for the filler as well)

The drain plug is located under the diff housing.

The filler plug is located on the left (nearside) off the gearbox (look to the left of the hole and you can see the 17mm hex filler bung).

Check you can undo the filler bung, then drain the gearbox oil.

Refit drain bung and fill gearbox through filler/level ********* until gearbox oil is up to the level of the filler bung.

Refit, test drive, check for leaks and retest level again when cold.

Cheers,

"If this has helped you in any way, please rate this solution" :-)

Hi Frank I am a technician with audi myself It may be that you require an engine e.c.u and not a gearbox one however has your A4 had any recalls carried out on the gearbox since purchase if not that would definately be something worth checking hope this helps.

you can use one off a vw passat

hi,i'm ck .my audi c5 2.4 model 2001, when put on D while driving, it go to neutral?