Question about 2004 Chrysler Pacifica
The fuel guage on my 2004 Chrysler Pacifica goes from the actual fuel level to empty repeatedly and the low fuel chime goes off. How do I fix this or how do I turn off the chime?
The problem will get worse, to the point that it will leave you stranded, out of gas. The solution is simple but most dealers don't catch it. They try fuel pumps, computer updates, sensors and the problem persists. You can fix this problem yourself and without spending a nickel. Want to know how I know? I've owned two Pacifica's and both have done this. Here's why: The Pacifica has a very unique and poorly designed fuel storage system. It uses what is refered to as a saddle tank. This is so they can use the same tank in both the all wheel drive and the front wheel drive versions. If you look underneath you will see it actually looks like two tanks. The driver side is the fill side and the passenger side is the delivery side. There are actually two fuel pumps, a main pump (pumps gas to the engine) and a equalization pump (pumps fuel from the the fill side to the delivery side of the saddle tank. The problem that you are experiencing carries with it several symptoms; running out of gas when the tank is half full, the gas gauge dropping suddenly at half full, and the inability to pump more gas into the tank without shaking the car back and forth and/or pumping very slowly. This is because of the way the two sending units inside the tank send their signals to the gas gauge and the fact that only when the fill side of the tank is 100% full, can some of the gas flow over the top of the hump to the delivery side tank. You can replace pumps all day long and most likely still have the problem. So what's the fix? It's simple. Underneath the vehicle, inline with the emissions lines going to the gas tank, about middle of the vehicle, there is a small plastic air inlet filter about the size of 50 cent piece mounted to the floor of the vehicle. It is responsible for venting the tanks pressure, allowing fuel to flow into the delivery side tank. It get's full of dirt and debris. Replace it a cost of about $3.50 or just blow it out with compressed air. If you don't want to do it yourself, help those dealers out - point them in the right direction, or else they will be running in circles trying to fix the problem. NOTE: this is only a problem on Pacifica's, not other vehicles. More info on this issue here; http://www.dodgeboard.com/forums/index.php?threads/my-crazy-gas-gauge.6381/
Posted on Jul 11, 2012
This is a simple service fix. It's a glitch in the computer system. Take it to the dealer and there is some sort of code they can enter to "update" the car's computer.
Mine does it occasionaly, it annoying, but not harmful.
I've heard of some that will act up for a while, then stop, while others, have acted up and them the fuel gauge stays on empty.
Talk to the dealer.
Posted on May 25, 2010
The fuel sending unit in the gas tank is bad you must drop the gas tank to fix also make sure to clean the ground wire and reinstall it on a clean surface
Posted on May 05, 2010
I own a 2005 Pacifica and the fuel gauge suddenly jumped from half full to empty. Brought it to the dealer- they replaced a sensor(it also would not allow the gas to be pumped in without holding down the lever on the gas pump-kept shutting off). This did not work. Brought it back- dealer fixed another sensor. Works better now but still not fixed (easier to pump gas into tank & gauge holds to just below half full). Have to keep track of mileage.
Posted on Jun 27, 2010
I had the same issue, I just went to the car salvage yard and picked up both pumps and it fixed the problem for me. It seems that the floater in the pumps were faulty or either the pumps themselves were bad. I could say that it worked for me by just replacing both pumps to fix the gauge issue... It seems like a pretty common issue with the pacificas. I hope that this will help anyone that has the same problem..
Posted on Jul 31, 2016
Save hours of searching online or wasting money on unnecessary repairs by talking to a 6YA Expert who can help you resolve this issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
Here's a link to this great service
Posted on Jan 02, 2017
Tips for a great answer:
May 08, 2018 | Mitsubishi Cars & Trucks
Jan 04, 2015 | 2007 Chrysler Pacifica FWD New Cars
Oct 25, 2012 | 2007 Chrysler Pacifica FWD New Cars
Sep 03, 2012 | 2004 Chrysler Pacifica
Feb 11, 2011 | 2004 Chrysler Pacifica
Oct 29, 2010 | 2006 Chrysler Pacifica
Jun 04, 2010 | 2000 Chrysler Sebring
Sep 06, 2009 | 2004 Chrysler Pacifica
Jul 31, 2009 | 2004 Chrysler Pacifica
10,867 people viewed this question
Usually answered in minutes!
Step 2: Please assign your manual to a product: